86 87
!Caution
•
The use of non reccomended cleaning solutions and disinfectants and the failure to
follow Micrel cleaning and disinfection procedure may result in product damage.
•
To avoid pump damage, cleaning / disinfectant solutions must be used according to the
below table and manufacturer reccommendations.
•
Do not use hard or pointed objects to clean any part of the pump.
•
Do not spray directly cleaning fluids on the pump.
•
Do not steam autoclave, ethylene oxide sterilise or immerse this Rythmic™ in any fluid.
•
Do not use UV radiation to disinfect the pump.
•
Do not use compressed air to dry the pump.
•
Do not mix the disinfectant with any other product or chemical.
•
Do not use solutions that contain: ammonia, amines, aldehyde, ammonium
compounds, alcohol, phenols, ethers, ketones, esters, aromatic H/C (benzene, xylene,
toluene, chlorobenzene, white spirit, paint thinner, e.t.c.), benzoic acid and benzoates,
chlorinated H/C solvents (trichlorethane, methylene chloride, chloroform, ethylene chloride,
e.t.c.), phosphoric acid in concentration above 10%, phosphates, acid solutions (citric acid,
sulphurous acid, acetic acid, hydrochloric acid) alkali bases (caustic potash, caustic soda,
ammonium hydroxide, e.t.c.), sodium hypocloride (bleach) solutions, ozone, acetylene,
loctite adhesives, varnish, gasoline, kerosene, naphtha, heptane, hexane, essential oils,
silicone fluid and iodine.
Chemical type Trade name / Manufacturer
1.1
Hydrogen Peroxide solution up to
10% w/w
Oxivir Spray E2n / JohnsonDiversey 0.1-1% w/w
SteriMax Sporicide Wipes / Aseptix (1% w/w)
Revital-Ox XL HLD / STERIS (2.3%)
1.2
Hydrogen Peroxide <1% w/w
& Phosphoric Acid <1% w/w
Percept / Diversey diluted 1:16
1.3
Hydrogen Peroxide 2.5% w/w
& Glycolic Acid 2.5% w/w
Indicin OxyWipe S / ECOLAB
2
Ethanol >95% aq. Solution (no
other ingredient)
3
Peracetic acid at 0.2-0.35%
4
Mild solution of soap water (PH:7-8)
Recommended Cleaning solutions and Disinfectants for Rythmic™
pumps’ exterior surface
To Next Page
Loading...