MAINTENANCE SCHEDULES 92Service Manual – Advenger, 2800ST, 3800ST, BR 755, BR 855
MAINTENANCE SCHEDULES
OPERATOR PREVENTIVE MAINTENANCE – MACHINE IN USE
MAINTENANCE ITEM Daily Weekly Monthly
Charge Batteries ●
Check/Clean Tanks & Hoses ●
Check/Clean/Adjust Squeegee ●
Check/Clean/Rotate Brushes/Pads ●
Empty/Clean Strainer Basket in Recovery Tank ●
Check/Clean Vacuum Shut-Off Float ●
Check/Clean vacuum motor foam lter(s) ●
Clean Hopper on Cylindrical System ●
Charge Batteries – full charge cycle 12-15 hrs ●
Check Each Battery Cell’s Water Level (wet batteries) ●
Check/Clean/Adjust Scrub Deck Side Skirts ●
Check/Clean Solution Filter ●
Clean Solution Trough on Cylindrical System ●
Purge Detergent System (If equipped) ●
Lubricate Steering Chain ●
Lubricate Pivot Points for Squeegee & Scrub Deck Linkage ●
Lubricate Side Skirt Adjustment Knobs (19)
●
Lubricate Steering Wheel Shaft Universal Joint (A)
●
Lubricate Front Roller Bumper (20)
●
Lubricate Squeegee Tilt Adjustment Knob (32)
●
(ST) Check for Squeegee Cable Bushing wear inside Steering Column.
Wear indicates need for replacement and cable adjustment (too tight)
●
FIGURE 43
To Next Page
Loading...
Need help?
General
