Aspen Avionics EFD1000

To Next Page

To Previous Page

EFD1000 Installation Manual

DOCUMENT # A-01-126-00 PAGE 49-225 Revision H

Bonding Strap

Attachment Screw

Rear View of PFD

Figure 6.2 – PFD Bonding Strap Connection

Figure 6.3 – PFD and Bracket Installation

Main Page

Table of Contents5
Introduction11
Part Numbers11
Authorized Configurations11
Installation Kit Contents12
Accessories Required but Not Supplied13
Optional Accessories Not Supplied13
Special Tools Required13
Vendor Information14
Warranty Registration14
Regulatory Compliance14
Techn Cal Standard Order14
Software Certification14
Environmental Compliance14
Equipment Specifications and Limitations15
Primary Flight Display (Pfd) & Configuration Module (CM)15
General Specifications15
Operational Specifications15
I/O Specifications15
Certification Specifications15
Design Eye Viewing Envelope16
Outline Drawing17
Remote Sensor Unit (Rsm)17
General Specifications17
Operational Specifications17
I/O Specifications18
Certification Specifications18
Outline Drawing18
Analog Converter Unit (Acu)19
General Specifications19
Operational Specifications19
I/O Specifications19
Certification Specifications19
Outline Drawing20
System Description21
Primary Flight Display (Pfd)21
Remote Sensor Module (Rsm)22
Configuration Module23
Analog Converter Unit (Acu)23
System Architecture24
Supported Installed Configurations25
Pilot Configurations25
Pro Digital Configuration26
Pro Configurations with Autopilot27
Pro Configuration with Autopilot and Digital/Analog VLOC28
Pro Configuration with Autopilot and Dual Analog Vloc29
Pre Modification Planning31
Pre Modification Checklist31
Requirements and Limitations32
Standby Attitude Positioning34
Standby Airspeed and Alt Meter Position Ng35
Directional Gyro/ HSI35
Back up Nav Indicator36
GPS Annunciators37
Aircraft Power Requirements37
EFD1000 Power Requirements37
Special Considerations for Aircraft Limited to VFR38
Conventional Landing Gear "Tail Dragger" Aircraft38
Part 135 Ifr Operations39
Setting V-Speed Textual Markers39
Optional Interfaces39
Autopilot39
GPS Navigator Basemap Compatibility40
Gpss42
GPS/ NAV Switching42
Sonalert42
Heading Output42
Second ACU43
Flush or Recess Mounting the PFD43
Mechanical Installation45
Unpacking and Inspecting Equipment45
Equipment Location Documentation45
Log Book Entry45
Weight and Balance45
Installation Limitations46
Equipment Bonding46
Cooling46
Pfd Installation47
Connecting the Internal Battery47
PFD Mounting Location47
Mounting Bracket Installation48
PFD Bonding Strap48
Pitot and Static Connections51
Quick Connector Installation51
Leak Check Requirements52
Rsm Installation52
Proposed RSM Location Check53
Pressur Zed Aircraft54
RSM Mounting on Composite or Fabric55
Second RSM Placement (MFD)55
RSM Mounting Angles55
RSM Doubler57
RSM Doubler Fabrication58
RSM Nstallation61
RSM Shim Fabrication (if Necessary)62
Acu Installation64
ACU Mounting64
Configuration Module Installation66
Electrical Installation67
Electrical Load Analysis67
Hirf/Lightning Requirements68
PFD to GPS/VLOC/ACU Wiring69
RSM Wiring70
Configuration Module wir Ng72
ACU Wiring72
Back up NAV Indicator Wiring72
Autopilot wir Ng72
Electrical Connections73
Pfd Electrical Specifications73
Power Input73
Tone (Sonalert) Output73
GPS Input73
ARINC 429 GPS Inputs75
ARINC 429 VLOC Input76
ARINC 429 GPS Output76
Acu Electrical Specifications76
Power Input76
Decision Height (DH) Input - PFD Software Version 1.1 or Later76
VLOC Receiver77
GPS Receiver77
Autopilot79
ARINC 429 GPS Output82
Pfd Pin out83
Rsm Pin out84
Configuration Module Pin out85
Acu Pin out85
Installation Wiring Diagrams89
Configuration and Equipment Checkout121
Test Equipment121
Wiring Verification121
Bonding Check - Far122
System Configuration123
Main Menu Access123
Menu Navigation123
Edit Mode123
Main Menu Configuration123
Installation Menu - Unit Configuration128
Rsm Calibration147
Calibration Overview147
RSM Calibration Procedure150
Heading Offset Adjustment153
Heading Accuracy Test154
Heading Interference Test154
Ground Test Procedure155
Indicated Airspeed Display156
Altitude Display156
System Leak Test156
Outside Air Temperature156
AHRS Sensor Test156
GPS Sensor Test156
NAV Receiver Sensor Test157
Backup Navigation Indicator158
Autopilot Sensor Test158
Flight Director Test159
Sonalert Test159
Decision Height DH) Test - PFD Software Version 1.1 or Later160
Ancillary Equipment Heading Check160
TAPES Configuration Check160
EMI Test160
Flight Control Nterference Check161
EFD Internal Battery Test161
Post Installation Flight Check162
Basic Adi Flight Checks162
Basic Hsi/Dg Flight Checks162
ILS Flight Checks (if no Autopilot, Otherwise Jump to Section 11.4)163
Autopilot Flight Checks (if Installed)163
Operation166
Pilot Controls166
Overview166
Power Control167
Display and Control Layout168
Control Knobs169
Setting Flight Instruments169
Knob Sync Function170
Hot Key Operation171
CDI and Bearing Pointer Source Selection173
Back Light Control174
Map Range Control175
Display Reversion Control and Abnormal Shutdown175
Primary Flight Instruments175
Attitude Indicator175
Airspeed Indicator177
Altimeter179
Vertical Speed Indicator (VSI)180
Rate of Turn Indicator181
Data Bar (TAS, GS, OAT, Winds, Barometric Pressure Set)181
Horizontal Situation Indicator181
Bearing Pointers185
Situational Awareness Map Display185
Autopilot Integration188
Main Menu192
Menu Controls192
Menu Options193
Environmental Qualification Forms196
Troubleshooting202
Installation Final Check Sheet208
Operator Configuration Checklist214
Instructions for Continued Airworthiness216

Aspen Avionics EFD1000 - Page 49

Table of Contents

Other manuals for Aspen Avionics EFD1000

Related product manuals