Equipment Technologies APACHE AS1010 - Page 10

Chapter 5: Lubrication and Maintenance
General Information . . . . . . . . . . . . . . . . 5-1
Apache Sprayer Service Interval Chart . 5-2
Before Initial Use . . . . . . . . . . . . . . . . . . 5-3
After First 10 Hours. . . . . . . . . . . . . . . . . 5-3
Adjust Boom . . . . . . . . . . . . . . . . . . . 5-3
As Required . . . . . . . . . . . . . . . . . . . . . . 5-5
Inspect Front Accumulator. . . . . . . . . 5-5
Daily . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
Grease Boom. . . . . . . . . . . . . . . . . . . 5-6
Flush Wet System . . . . . . . . . . . . . . . 5-8
Check Tire Pressure . . . . . . . . . . . . . 5-8
Check Engine Oil Level . . . . . . . . . . . 5-8
Check Cooling System . . . . . . . . . . . 5-9
Check Brake Fluid Level . . . . . . . . . . 5-9
Check Transmission Fluid Level . . . 5-10
Check Hydraulic Fluid Level . . . . . . 5-11
Check A/C Compressor Belt . . . . . . 5-11
Every 40 Hours . . . . . . . . . . . . . . . . . . . 5-12
Torque Lug Nuts . . . . . . . . . . . . . . . 5-12
Grease Steering Components . . . . . 5-12
Grease Axle Components . . . . . . . . 5-13
Torque Boom Lead Bolts. . . . . . . . . 5-13
Check Differential Fluid Level . . . . . 5-14
Check Rear Differential for Leaks . . 5-14
Re-Phase Steering Cylinders . . . . . 5-14
After First 100 Hours. . . . . . . . . . . . . . . 5-15
Every 100 Hours . . . . . . . . . . . . . . . . . . 5-15
Grease Driveline Components . . . . 5-15
Check Axle Extension Bolt Torque . 5-16
Adjust Poly Tank Straps
(if equipped). . . . . . . . . . . . . . . . . . . 5-17
Replace Fuel Filter . . . . . . . . . . . . . 5-17
Replace Fuel Separator Filter . . . . . 5-17
Every 250 Hours . . . . . . . . . . . . . . . . . . 5-18
Clean or Replace Engine Primary
Air Filter . . . . . . . . . . . . . . . . . . . . . . 5-18
Replace Differential Fluid . . . . . . . . 5-19
Replace Hydraulic Fluid Filter . . . . . 5-19
Clean Hydraulic Fluid Strainers . . . . 5-20
Every 500 Hours or Yearly . . . . . . . . . . 5-21
Check Accumulator Fluid Level . . . . 5-21
Replace Fuel Filter. . . . . . . . . . . . . . 5-21
Replace Fuel Separator Filter . . . . . 5-22
Replace Planetary Fluid
(AS 1010 Only) . . . . . . . . . . . . . . . . 5-22
Replace Steering Pressure Filter. . . 5-23
Replace Engine Oil and Filter . . . . . 5-23
Replace Transmission Fluid
and Filter . . . . . . . . . . . . . . . . . . . . . 5-24
Recalibrate Raven Radar Gun. . . . . 5-26
Inspect and Repack Wheel
and Inter-Flex Bearings . . . . . . . . . . 5-26
Every Year . . . . . . . . . . . . . . . . . . . . . . 5-27
Adjust Toe-In . . . . . . . . . . . . . . . . . . 5-27
Replace Engine Safety Air Filter . . . 5-28
Winterize Wet System . . . . . . . . . . . 5-28
Replace Cab Recirculating
Air Filter . . . . . . . . . . . . . . . . . . . . . . 5-31
Replace Cab Charcoal
Air Filter . . . . . . . . . . . . . . . . . . . . . . 5-31
Replace Drop Box Fluid. . . . . . . . . . 5-32
Check Front Suspension
Accumulator Charge . . . . . . . . . . . . 5-32
Every 1000 Hours or Yearly . . . . . . . . . 5-33
Clean Transmission Fluid Strainer. . 5-33
Replace Hydraulic Fluid . . . . . . . . . . 5-33
Chapter 6: Cummins Engine Fault Codes
Chapter 7: Torque Value Charts
Fittings. . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1
Bolts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
Chapter 8: Troubleshooting
Apache Sprayer Troubleshooting Symptoms
and Solutions . . . . . . . . . . . . . . . . . . . . . 8-1
Chapter 9: System Schematics
Hydraulic System . . . . . . . . . . . . . . . . . . 9-1
Electrical System (Sheet 1 of 5) . . . . . . . 9-2
Electrical System (Sheet 2 of 5) . . . . . . . 9-3
Electrical System (Sheet 3 of 5) . . . . . . . 9-4
Electrical System (Sheet 4 of 5) . . . . . . . 9-5
Electrical System (Sheet 5 of 5) . . . . . . . 9-6
Chapter 10: Warranty
Equipment Technologies Warranty Policy10-1