Generac Power Systems CorePower User Manual

PART 4
ENGINE/DC CONTROL
Page 58
Section 4.4
Troubleshooting Flowcharts
CONTACT
TECHNICAL
SERVICE
BAD
REPLACE CHOKE
SOLENOID
CLEAN,
REGAP OR
REPLACE
REPLACE CONTROLLER
REPLACE FUEL SOLENOID
TEST 60 – CHECK
FUEL SUPPLY AND
PRESSURE
REPLACE FUEL
REGULATOR
TEST 64 –
CHECK FOR
IGNITION
SPARK
TEST 63 – CHECK
CHOKE SOLENOID
TEST 67 – CHECK
IGNITION
MAGNETO
TEST 79 – CHECK
SHUTDOWN WIRE
TEST 70 –
CHECK AND
ADJUST VALVES
TEST 65 –
CHECK SPARK
PLUGS
TEST 66 –
CHECK ENGINE
COMPRESSION
TEST 62 – CHECK
FUEL SOLENOID
TEST 61 – CHECK
CONTROLLER
WIRE 14 OUTPUT
GOOD
GOOD
GOOD
GOOD
GOOD
GOOD
GOOD
GOOD
GOOD
GOOD
BAD
BAD
BAD
BAD
BAD
BAD
BAD
BAD
BAD
ADJUST OR
REPLACE
REPAIR OR
REPLACE SHORTED
WIRE 18 OR
CONTROLLER
CHECK
FLYWHEEL
KEY
FIND AND CORRECT
CAUSE OF NO FUEL
OR LOW PRESSURE
READJUST
Problem 22 – Engine Cranks but Won’t Start
CHECK AIR FILTER -
REPLACE AS NEEDED

Generac Power Systems CorePower Specifications

General

Brand	Generac Power Systems
Model	CorePower
Category	Portable Generator
Language	English