Hamilton Jet HTX30 User Manual (English)

To Next Page

HTX30

HTX30 Product Manual

R0A5

blue ARROW

Table of Contents3
Introduction9
Limited Warranty9
General Safety Notice11
About this Manual12
System Overview13
Installation and Commissioning Overview13
Installation Steps14
Component Overview14
Station Control Panel15
Dual Lever Modules15
Helm Wheel Module15
Mouseboat Manoeuvring Controller16
Jet Interface Module17
Engine Interface Module17
External Control Interface Module17
Jetanchor Control Module18
Jetanchor GPS Components18
Alarm Sounder18
Network Terminators19
System Cables19
System Design21
Mounting the Modules22
Cabling23
Power Supplies24
Precautions against Corrosion25
Engine Start Interlock By-Pass25
Component Installation27
Tools27
Installation28
Power Supply28
Engine Interface Module28
Jet Interface Module28
Station Control Panel28
Control Input Devices29
Alarm Sounder29
Autopilot29
Interconnecting Cables30
Jetanchor Control Module33
Jetanchor GPS Antenna34
External Control Interface Module37
External CAN Bus Terminators39
Internal CAN Bus Terminators40
Station Control Panel - after Installation Checks41
Power Checks42
General Checks42
Commissioning43
Before Launch Setup43
The Blue ARROW Support Tool43
Overview44
Tasks44
Start a New Commissioning44
Before Starting45
Commissioning Details46
Programming the Modules47
Configuring the Network48
Module Set up48
Engine Interface Module Set up49
Station Control Panel Set up51
Jet Interface Module Set up54
External Control Interface Set up56
Jetanchor Control Module Set up57
System Checks63
The Hydraulic System63
Sea Trialling64
Control Checks64
Engine Checks64
Jet Setup65
Jet Unit Checks66
General Checks67
At Sea68
Tuning the System69
After Operation70
System Registration70
Jetanchor Commissioning70
Prerequisites for Jetanchor Auto Tuning71
Start Jetanchor Autotune73
How to Manually Terminate an Autotune Test74
Automatic Termination of Autotune Tests75
Autotune Tests76
Closing Jetanchor Autotune86
Verifying Jetanchor Performance86
Autotune Error Messages87
Fault Finding93
Alerts95
Alert Priorities95
Alarm Browser96
Alarm and Warning Codes97
Alarm Summary98
Maintenance107
General107
Threaded Fasteners107
Tools and Accessories108
Servicing Hydraulic Equipment108
Deck Mounted Controls108
Preservation: Pre Installation109
Service Intervals110
Servicing Details110
JHPU Oil110
Oil Filter111
Oil Coolers111
Feedback Sensors111
V-Belts111
System Hoses and Tubing113
Servicing Details (Electronic System)113
Normal Operation113
Backup Operation113
Station Control Panel113
Jet Interface Module113
Modules General114
Cables and Connectors114
Appendix115
Conversions116
85144 Loctite Application Guide117
General Practice117
Primers, Activators and Accelerators117
Equivalents118
85113 Tightening Torques127
Nut Tightening Torques127
Screw Tightening Torques128
Stud Installation129
Set Screws130
Hydraulic Cylinder Piston130
Hydraulic Fittings131
Thread Lubricants132
Blue ARROW Module Dimensions132
Module Inputs and Outputs138
Jet Loom Pin Assignments140
Installation and Commissioning Check Sheets142
After Installation Checks142
Before Launch Checks144
After Sea Trials147
Configurable Parameters148
Accessing Parameters Via the SCP148
Configurable Parameter Navigation Tree150
Configurable Parameter Details156
EIM Parameters158
JIM Parameters161
SCP Parameters166
XCI Parameters169
JACM Parameters171
Glossary176
Technical Drawings177

Need help?

Do you have a question about the Hamilton Jet HTX30 and is the answer not in the manual?

Hamilton Jet HTX30 Specifications

General

Brand	Hamilton Jet
Model	HTX30
Category	Boating Equipment
Language	English

Related product manuals

Hamilton Jet HTX30 User Manual

Table of Contents

Hamilton Jet HTX30 Specifications

Related product manuals