MacDon 9200 - Page 116

TROUBLE SHOOTING
SYMPTOM
PROBLEM
SOWDON
REF.
Engine hard to start or Water, dirt or air in fuel Drain, flush, fill and
67
will not start. (cont'd) system .
bleed system.
Improper type of fuel .
Use proper fue' for
53
operating conditions.
Diesel: Hand lever on
Push lever down.
67
lift pump raised.
Crankcase oil too Use recommended oil.
54
heavy .
Low battery output. Have battery tested.
74
Check battery electro-
lyte level .
Poor battery Oean and tighten loose
74
connection. connections.
Faulty starter. Repair or reptace.
*
Wiring shorted, circuit
Check continuity of
79
breaker open . wiring and breaker
(manual reset).
Diesel engine - faulty
Oean or replace
*
Injectors.
injectors.
Engine knocks.
Insufficient
oil. Add oil.
58
Engine out of time.
Diesel - Time injection
*
pump.
Low or high coolant Remove and check
*
temperature .
thermostat. See "Engine
Overheats· ,
Improper fuel.
Use proper fuel.
53
Low oil pressure.
Low oil leve l. Add oil.
58
Improper type of oil.
Drain, fill crankcase with
54
proper aD .
Worn components.
Repair engine.
*
HIgh oil consumptIon. Crankcase oil too light.
Use recommended oil.
54
om leaks .
Check for leaks around
gaskets,
seals, and
drain plugs.
Intemal parts worn.
Check for worn parts.
*
.. See your WineJrower dealer.
118