CHASSIS INFORMATION - 10
206
CAY M A N 2 0 0 7
Changing the hydraulic oil fi lter:
1. Loosen the center cover bolt with a
15/16" wrench.
2. Remove the bolt and cover plate to
access the spring and lter.
3. Remove the spring and washer to
remove the lter assembly.
4. Replace the lter assembly, and
reverse the process to re-assemble the
reservoir.
5. Check for damage when attaching the
cover plate in the rubber cover seal.
AIR FILTER
Air Filter Minder
The air lter restriction indicator relays the
amount of restriction present in the air intake
system and should be inspected before each trip.
If the yellow indicator approaches the red (top)
area of the air restriction indicator, it is signaling
that the air lter is becoming excessively dirty.
Changing the Filter
The air cleaner is located in the rear roadside
bay. To replace air cleaner remove screws and
cover from air cleaner body. Remove air cleaner
cartridge and discard. Install new air cleaner
cartridge and secure with cover and screws.
WARNING:
DO NOT start the engine with the air
cleaner removed and do not remove it
while the engine is running.
LUBRICATION MAINTENANCE
Performing regular scheduled maintenance
ensures reliable operation and optimum
service life of the various chassis components.
Completed maintenance brings peace of mind
knowing the various components have received
proper service. Failure to follow maintenance
guidelines, or perform scheduled maintenance,
results in inef cient operation, premature
component wear or component failure resulting
in breakdown.
Maintenance schedules are usually performed
at certain mile or time intervals. When
performing high level procedures, lower level
service should also be performed.
NOTE:
Maintenance schedules are based on
normal operating conditions and use.
Operating under unusual or adverse
condition shortens service intervals.
NOTE:
Engine and transmission service
intervals are listed in their respective
manuals.
Proper Lubricant Waste Disposal:
When performing service maintenance on
the engine, transmission or rear axle, waste
uids and lters should be properly disposed of
or recycled. Package used oils, antifreeze and
other uids in sealed containers. In many cases
used oil is accepted free of charge at county
disposal sites. Waste uids are toxic to pets and
other animals. Waste uids should not be left in
open containers. The sweet odor of antifreeze is
attractive to pets, but highly toxic.
CAUTION:
Properly dispose of used antifreeze
and waste oil. Animals like the sweet
odor of antifreeze and may ingest it if
left in open containers. Wipe up any
fluid spills. Pets may lie in puddles of
fluid, many of which are irritants and
can cause severe chemical burns if not
properly washed.
090464
Located in rear roadside compartment.
Air cleaner located in the
rear roadside bay.
090317
To Next Page
Loading...