CHASSIS INFORMATION - 10
209
CAY M A N 2 0 0 7
Component: Action: When: Code
1. Engine Oil Dipstick Keep to Full Mark Before Each Trip + Daily Enroute EO
1 a. Engine Oil Fill Drain Refer to OEM Manual OEM
2. Engine Oil Filter Replace At Oil Change OEM
3. Transmission Keep to Full Mark Refer to OEM Manual TS
3a. Transmission Filter Replace Refer to OEM Manual OEN
4. Engine Coolant Surge Tank Maintain Level Before Each Trip + Daily Enroute AF
5. Hydraulic Fluid Reservoir Maintain Level Before Each Trip + Daily Enroute TF
6. Hydraulic Filter Replace 15,000 or Annually TF
7.
Filter Fuel/Water Separator
(Primary)
Inspect/Replace Before Each Trip/15,000 or 6 Months FF
8. Filter Fuel (Secondary) Replace Refer to OEM Manual FF
9. Radiator/Charge Air Cooler Inspect Weekly OEM
10. Slack Adjuster/Cam Shaft Grease-2 Fittings ea. 10,000 or 3 Months CL
11. Rear Differential Change Fluid 250,000 or 3 Years MP
12. Drive Shaft Universal Joints Grease-2 Fittings 5,000 or 6 Months CL
13. Drive Shaft Slip Yoke Grease-1 Fitting 5,000 or 6 Months CL
14. Drag Link Grease-2 Fittings 5,000 or 6 Months CL
15. Center Link Grease-2 Fittings 5,000 or 6 Months CL
16. Spindles/Kingpins Grease-2 Fittings ea. 5,000 or 6 Months CL
17. Intermediate Steering Shaft Grease-3 Fittings 30,000 or Annually CL
18. Air Tank Drains Drains Monthly -
19. Leveler Reservoir Keep to Full Mark 6,000 or 3 Months TF
20. Tire Pressure Check Before Each Trip + Daily En route -
21. Generator Refer to OEM Manual Refer to OEM Manual OEM
22. Batteries Inspect Every 2 Weeks DW
Battery Terminals Apply Coating 10,000 or Quarterly P
23. Air Filter Minder Inspect Before Each Trip + Daily En route --
24. Transmission Remote Fill -- -- --
NOTE:
Service must be performed every twelve (12) months, regardless of actual mileage, to protect seals, bearings and gaskets from drying out
and failing. The motorhome must be started and driven for at least 20 miles every two weeks. It is important to remember the generator
maintenance interval is based on hours of usage. Consult the OEM manual for the generator service interval.
Lubrication Code Chart:
*EO
Engine oil as recommended by
engine manufacturer. Texaco URSA
Super Plus SAE 15w-40.
*OEM
Refer to the Original Equipment
Manufacturer’s manual.
MP
API GL-5 or MT-1 type gear lubricant
- Texaco Star Gear SAE 80w-90
Non-Synthetic
*CL
Chassis lubricant should be a high
quality non corrosive multi-purpose
lithium soap base lubricant that is
water resistant and designed to
withstand extremely high operating
temperatures. Texaco Starplex
NLGI2
*TF
Transmission fl uid. Use Dexron III®
transmission fl uid only.
*AF Texaco 50/50 with bitterant and SCA.
FF Fuel Filter
HT High Temperature Bearing Grease
*TS TranSynd™
DW Distilled Water
P Petroleum Jelly
*Fluids initially fi lled at factory.
To Next Page
Loading...
