Schaerer 7300 - Page 2

To Next Page

To Previous Page

Main Page

Table of Contents3
Important Instructions6
General Safety Instructions6
Warnings6
Warranty Instructions6
Section I General Information7
- 1.1 Scope of Manual7
- 1.2 How to Use Manual7
- Description of 7300 Modular Surgery Table7
- 1.4 Specifications13
- 1.5 Parts Replacement Ordering14
- 1.6 Special Tools15
Section II Testing and Troubleshooting17
- 2.1 Operational Test17
- 2.2 Troubleshooting Procedures22
Section III Scheduled Maintenance33
- Scheduled Maintenance33
- 4.1 Introduction35
- Checking Oil Level / Adding Oil to Reservoir35
- Calibration of Return to Level / Neutral Position36
- Hand Control Button Board Removal / Installation38
- Hand Control Board Removal / Installation38
- Seat Cylinders Synchronization Procedure39
- Column Cylinder Slave Line Volume Adjustment41
- Special Tools41
- Trendelenburg Cylinder Removal / Installation43
- Trendelenburg Pilot Operated Check Valve Removal / Installation45
- Trendelenburg Cylinder Orifice(S) Removal / Installation47
- Trendelenburg Position Sensor Removal / Installation48
- Lateral Tilt Cylinder Removal / Installation49
Lateral Tilt Orifice(S) Removal / Installation50
Lateral Tilt Pilot Operated Check Valve Removal / Installation52
Lateral Tilt Position Sensor Removal / Installation54
Seat Cylinder Removal / Installation55
Seat Cylinder Orifice(S) Removal / Installation60
Seat Cylinder Pilot Operated Check Valve Removal / Installation61
Seat Position Sensor Removal / Installation62
Column Cylinder Removal / Installation65
Column Pilot Operated Check Valve Removal / Installation68
Typical L.H. and R.H. Control Valve Solenoids Removal / Installation69
Typical Base Mounted Control Valve Solenoids Removal / Installation71
Discharge Filter Replacement73
Main Floor Lock or Outrigger Floor Lock Cylinder Removal / Installation75
Motor or Motor Pump Removal / Installation76
Pump Unit Removal / Installation79
Motor Pump Output Check Valve Removal / Installation81
Motor Pump Pressure Relief Valve Removal / Installation82
Outrigger Pressure Relief Valve Removal / Installation84
Main Controller Board Removal / Installation87
Charging / Power Driver Board Removal / Installation89
Emergency Override Panel Removal / Installation91
Distribution Board Removal / Installation92
RFI Filter Removal / Installation93
- Transformer Removal / Installation95
- Line Power Pilot Lamp Removal / Installation97
- Plug Receptacle Removal / Installation97
- Batteries Removal / Installation98
- Primary Thermostat Removal / Installation99
- Secondary Thermostat Removal / Installation100
- Floor Lock Status Switch Removal / Installation100
- Head Section Gas Spring Removal / Installation / Adjustment102
- Foot Control Interface Board Removal / Installation103
- Typical Latch Mechanism Removal / Installation104
- Typical Floor Lock Check Valve Removal / Installation105
- Articulating Leg Transfer Board107
- Bell Footpiece Traction Crank Assembly109
Section V Schematics and Diagrams111
- Electrical Schematics / Wiring Diagrams111
- 5.2 Hydraulic Flow Diagram114
- 5.3 Hand Control Messages115
- 5.4 Error Code Chart116
Section VI Parts List117
- 6.1 Introduction117
- 6.2 Description of Columns117
- Torque Specifications and Important Assembly Notes117
  - Pictorial Index118
10360 Safety Strap155
10395 Lottes Anklet156
10508 Well Leg Support Assembly157
10509 Equipment Cart158
10620 Drape Stand Assembly159
10821 Removable Siderail160
10823 Leg Transfer Board161
10825 Tibia Extender163
10830 Well Leg Support (Siderail Mount)164
10836 Offset Adapter Mount165
13100 / 13200 Montreal Lateral Position Device166
22111 Pin and Wire Holder167
22119 Traction Bow Assembly168
22314 Traction Cuff Assembly169
70542 Bierhoff Leg Holder170
70556 Siderail Extension Set171
71070 Siderail Socket172
71071 I.V. Arm Board Assembly173
71073 Siderail Clamp174
71074 Conventional Ether Screen175
71075 Foot Rest176
71077 Siderail Extender Set177
71078 A/P Cassette Holder178
71079 Lithotomy Leg Holder179
71080 Universal Ether Screen180
71082 Lateral Cassette Holder181
71083 Cross Arm Support182
Cushion183
71088 Neuro Headrest Adapter184
71090 Lateral Support Set185
71092 Infant Arm & Hand Table186
71094 Table Side Extenders187
71097 Tri Clamp 2188
71098 Flexguard Stirrup Set189
71099 Guardian Stirrup Set190
71100 Leg Prep Stand191
71101 Snaplock Arm Board192
71102 / 71103 Snaplock Arm Board Cushion193
71104 Shoulder Brace Set194
71105 Universal Patient Brace 71113 Circular Head Cushion195
71106 / 71107 Uro Catch Bags196
71108 Winged Anesthesia Screen197
71110 Footswitch198
71111 Split Leg Set 71118 / 71119 Split Leg Pad Set199
71114 Foot Extension Cushion200
71116 Conductive Safety Strap 20715 Nonconductive Safety Strap201
71120 Side Extender Shelf202
71129 X-Ray Armboard204
71130 I.A. Board (36-Inch)205
73001 Pelvic Base W/ Cushion206
73002 Leg Transfer Board W/ Cushion207
73003 Drain Pan208
73005 X-Ray Top Set210
73006 Back Section211
73007 Ortho Pelvic Base 73023, 73024 Board W/ Cushion212
73008 Abductor Bar213
73009 Abductor Bar Clamp214
73011 Traction Unit Extention216
73012 Popliteal Support217
73013 Lateral Well Leg Holder218
73014 Shoulder Arthroscopic Attachment219
Shoulder Arthroscopic Lumbar Support Assembly219
Shoulder Arthroscopic Head Rest219
73015 Articulating Bracket222
73016 Drapery Kit223
73019 Back Section X-Ray Top224
73020 Leg Transfer Frame225
73025 Orthopedic Cart227
73026 General Surgery Cart228
Charlemar Drive Cincinnati, Ohio229
Comments229

Schaerer 7300 - Page 2

Table of Contents

Other manuals for Schaerer 7300