Schaerer 7300 - Table of Contents

TABLE OF CONTENTS
Section/Paragraph Page Section/Paragraph Page
4.13 Lateral Tilt Orifice(s)
Removal / Installation ............................. 4-16
4.14 Lateral Tilt Pilot Operated Check Valve
Removal / Installation ............................. 4-18
4.15 Lateral Tilt Position Sensor
Removal / Installation ............................. 4-20
4.16 Seat Cylinder
Removal / Installation ............................. 4-21
4.17 Seat Cylinder Orifice(s)
Removal / Installation ............................. 4-26
4.18 Seat Cylinder Pilot Operated Check Valve
Removal / Installation ............................. 4-27
4.19 Seat Position Sensor
Removal / Installation ............................. 4-28
4.20 Column Cylinder
Removal / Installation ............................. 4-31
4.21 Column Pilot Operated Check Valve
Removal / Installation ............................. 4-34
4.22 Typical L.H. and R.H. Control Valve Solenoids
Removal / Installation ............................. 4-35
4.23 Typical Base Mounted Control Valve Solenoids
Removal / Installation ............................. 4-37
4.24 Discharge Filter Replacement .................... 4-39
4.25 Main Floor Lock or Outrigger
Floor Lock Cylinder
Removal / Installation ............................. 4-41
4.26 Motor Or Motor Pump
Removal / Installation ............................. 4-42
4.27 Pump Unit
Removal / Installation ............................. 4-44
4.28 Motor Pump Output Check Valve
Removal / Installation ............................. 4-47
4.29 Motor Pump Pressure Relief Valve
Removal / Installation ............................. 4-48
4.30 Outrigger Pressure Relief Valve
Removal / Installation ............................. 4-50
4.31 Main Controller Board
Removal / Installation ............................. 4-53
4.32 Charging / Power Driver Board
Removal / Installation ............................. 4-55
4.33 Emergency Override Panel
Removal / Installation ............................. 4-57
4.34 Distribution Board
Removal / Installation ............................. 4-58
4.35 RFI Filter
Removal / Installation ............................. 4-59
(*) Indicates that there has been a serial number break for the illustration
and that there are additional point page(s) following the original page.
IMPORTANT INSTRUCTIONS
General Safety Instructions........................................ iv
Warnings.................................................................... iv
Warranty Instructions ................................................. iv
SECTION I GENERAL INFORMATION
1.1 Scope of Manual ......................................... 1-1
1.2 How to Use Manual ..................................... 1-1
1.3 Description of 7300 Modular Surgery
Table ....................................................... 1-1
1.4 Specifications ............................................. 1-7
1.5 Parts Replacement Ordering ....................... 1-8
1.6 Special Tools .............................................. 1-9
SECTION II TESTING AND TROUBLESHOOTING
2.1 Operational Test .......................................... 2-1
2.2 Troubleshooting Procedures ........................ 2-6
SECTION III SCHEDULED MAINTENANCE
3.1 Scheduled Maintenance .............................. 3-1
SECTION IV MAINTENANCE/SERVICE
INSTRUCTIONS
4.1 Introduction ................................................. 4-1
4.2 Checking Oil Level / Adding Oil To
Reservoir .................................................. 4-1
4.3 Calibration Of Return To Level / Neutral
Position .................................................... 4-2
4.4 Hand Control Button Board
Removal / Installation ............................... 4-4
4.5 Hand Control Board
Removal / Installation ............................... 4-4
4.6 Seat Cylinders Synchronization
Procedure ................................................. 4-5
4.7 Column Cylinder Slave Line Volume
Adjustment ............................................... 4-7
4.8 Trendelenburg Cylinder
Removal / Installation ............................... 4-9
4.9 Trendelenburg Pilot Operated Check Valve
Removal / Installation ............................. 4-11
4.10 Trendelenburg Cylinder Orifice(s)
Removal / Installation ............................. 4-13
4.11 Trendelenburg Position Sensor
Removal / Installation ............................. 4-14
4.12 Lateral Tilt Cylinder
Removal / Installation ............................. 4-15
© Schaerer Mayfield USA, Inc. 2004 Page iPrinted in U.S.A.