Suzuki LT-R450K6 - Starter Motor Reassembly

8-14 ELECTRICAL SYSTEM
ARMATURE COIL INSPECTION
Check for continuity between each segment and between each
segment and the armature shaft using the multi-circuit tester.
If there is no continuity between the segments or there is conti-
nuity between the segments and shaft, replace the armature
with
a new one.
09900-25008: MUM-circuit tester set
I:@ Tester knob indication: Contlnulty test (-11))
OIL SEAL INSPECTION
Check the oil seal lip for damage or leakage.
If any damage is found, replace the housing end
STARTER MOTOR REASSEMBLY
Reassemble the starter motor in the reverse order of disassem-
bly. Pay attention to the following points:
Apply SUZUKI SUPER GREASE to the lip of the oil seal.
& 99000-25010: SUZUKl SUPER GREASE "A"
(or equivalent grease)
"&
Apply a small quantity of SUZUKl MOLY PASTE to the arma-
ture shaft.
& 99000-25140: SUZUKl MOLY PASTE
Align the match mark on the starter motor case with the match
marks on the housing end.