CHK
ADJ
Periodic checks and adjustments
3-3
60C5D11
NOTE:
(*1) If equipped with a portable fuel tank.
(*2) Be sure to replace the timing belt every 1,000 hours of operation or every five years.
(*3) Do not adjust the carburetor if it is operating correctly.
(*4) The engine should be flushed with fresh water after operating in salt, turbid, or muddy water.
(*5) Do not retighten the cylinder head and crankcase bolts.
Lower unit
Gear oil Change 3-13
Impeller/Woodruff key Check/replace 6-8,
6-36
Oil seals Check/replace —
Drive shaft Check/replace 6-18,
6-46
Propeller Check 3-14
General
Anodes/Trim tab Check/replace 3-14
Battery Check/charge 3-15
Wiring and connectors Adjust/reconnect —
Nuts and bolts
(*5)
Tighten —
Lubrication points Lubricate 3-16
Rubber seals Replace —
Bearings Check/replace —
Exhaust system
deterioration
Check/replace —
Item Remarks
Initial Every
Refer to
page
10 hours
(Break-in)
50 hours
(3 months)
100 hours
(6 months)
200 hours
(1 year)
500 hours
(every 30 months)
1000 hours
(every 5 years)
To Next Page
