Case 385 Diesel - Page 5

CONDENSED SERVICE DATA (CONT.)
TUNE-UP
Compression Pressure
Firinc Order
385
Diesel
1-3-2
485
Diesel
1-3-2
585
Diesel
315-340 psi (2)
(2172-2344 kPa)
685
Diesel
1-3-4-2
885
Diesel
Valve Tkppet Gap (Hot),
Intake and Exhaust
Valve Face Angle
Valve Seat Angle
Ir\jection Pump Make
Ir\jection Pump Timing ....
Engine Low Idle — Rpm . .
Engine High Idle — Rpm
(No Load) 2340 2480
Engine Full Load — Rpm .. 2200 2180
(2) Approximate psi (kPa), at sea level, at cranking speed.
0.012 in.
(0.304 mm)
45°
44°
_ Robert Bosch _
See Paragraph 61.
725-750
2590
2300
2705
2300
2650
2400
SIZES-CLEARANCES-CAPACmES
Crankshaft Main Journal
Diameter
Crankpin Diameter
Camshaft Journal Diameter
Piston Pin Diameter
Valve Stem Diameter,
Intake
Exhaust
Main Bearing Diametral
Clearance .
Rod Bearing Diametral
Clearance
Piston Skirt Diametral
Clearance
Crankshaft End Play
Camshaft Bearing
Diametral Clearance ....
Camshaft End Play
Cooling System Capacity . .
Crankcase Oil (With Filter)
. 3.0 U.S. gal.
(11.4 L)
. 8 U.S. qts.
(7.5 L)
. 3.1484-3.1492 in. _
(79.97-79.99 mm)
. 2.5185-2.5193 in. _
(63.97-63.99 mm)
. 2.2823-2.2835 in. _
(57.97-58.00 mm)
_ 1.4172-1.4174 in. .
(35.997-36.002 mm)
. 0.3920-0.3924 in. .
(9.957-9.967 mm)
_ 0.3912-0.3915 in. _
(9.936-9.945 mm)
. 0.0028-0.0055 in. .
(0.071-0.140 mm)
_0.002-0.004 in. _
(0.051-0.102 mm)
0.0035-0.0050 in.
(0.09-0.13 mm)
_ 0.006-0.009 in. _
(0.152-0.229 mm)
0.0009-0.0033 in.
(0.023-0.084 mm)
_ 0.004-0.018 in._
(0.10-0.45 mm)
. 3.6 U.S. gal.
(13.7L)
. 10 U.S. qts.
(9.5 L)
6
www.maskinisten.net