SECTION 21 - TRANSMISSION 5
1.2 MOUNTING SCREW TORQUE
Strainer bolts....................................................................................................................................18 to 31 Nm
Pump retaining bolts ........................................................................................................................18 to 31 Nm
Output Yoke bolts ............................................................................................................................68 to 88 Nm
Pressure test plugs ..........................................................................................................................41 to 54 Nm
Main transmission case bolts...........................................................................................................45 to 64 Nm
Shift detent plug ............................................................................................................................... 41 to 54 Nm
Shift fork screws...............................................................................................................................18 to 25 Nm
Shift lever assembly screws.............................................................................................................16 to 24 Nm
Drain plugs.......................................................................................................................................34 to 54 Nm
Relief valve ......................................................................................................................................23 to 30 Nm
Pressure regulator valve .................................................................................................................. 46 to 60 Nm
Cold start valve ................................................................................................................................46 to 60 Nm
4WD solenoid valve spool................................................................................................................20 to 27 Nm
4WD Solenoid coil retaining nut...............................................................................................................5.4 Nm
Control valve retaining screws .......................................................................................................6.8 to 8.5 Nm
4WD hydraulic pipe connections.................................................................................................. 6.8 to 10.2 Nm
Filter housing bolts...........................................................................................................................45 to 64 Nm
Oil filter...............................................................................................................................................7 to 10 Nm
Temperature sender ........................................................................................................................20 to 27 Nm
RECOMMENDED SEALANTS
Transmission case joint ................................................................................................................... Loctite 5203
4WD Output gear ...............................................................................................................................Loctite 649
4WD gear (Permanent 4WD assy) ....................................................................................................Loctite 649
4WD clutch supply pipe .....................................................................................................................Loctite 542
Gear lever housing...................................................................................................................Loctite 5900 RTV
Shimming access plug .......................................................................................................................Loctite 649
To Next Page
Loading...
