GENERAL INFORMATION CU800 Service Manual
36
1.14 MAINTENCE AND ADJUSTMENT OF THE EV
To ensure trouble-free vehicle performance, it is very important to follow an established
preventive maintenance program. Meanwhile, regular maintenance can greatly extend the service life
of EV.
Regular and consistent vehicle maintenance can prevent vehicle downtime and expensive
repairing cost that could be resulted because of neglect. This will also prevent further damage to the
vehicle and avoid the possibility of injury.
If you are not eligible or technologically limited for regulated maintenance, please contact your
local distributor/dealer to perform all repairs or semiannual or annual periodic service.
NOTE
⚫ If any problems are found during scheduled inspection or service, do not operate the
vehicle until repairs are made. Failure to make necessary repairs could result in fire,
property damage, severe personal injury, or death.
⚫ Only trained technicians could serve or repair the vehicle and its battery charger. The
appropriate instructions must be used when performing maintenance, service, or
accessory installation.
⚫ Hot! Do not attempt to serve a hot motor.
⚫ To avoid unintentionally starting the vehicle during the process of repairing, please
disconnect the battery.
⚫ After disconnecting the batteries, wait 90 seconds for the controller capacitors to
discharge. The maintenance can be done only after this step.
⚫ To maintain the EVs or battery chargers, you must wear certified safety glasses to
protect eyes. When working nearby the battery, you must wear face shield and rubber
gloves.
⚫ When maintaining close to the electrical system or upon the electrical system, use the
insulated tools. To be more careful to avoid parts or electrical short circuit.
⚫ Both the Periodic Service Schedule and Periodic Lubrication Schedule must be
followed to keep vehicle in optimum operating condition.
⚫ If the vehicle is constantly subjected to heavy use or used under severe operating
conditions, the frequency of the preventive maintenance procedure should increase,
compared with that recommended in the periodic service and lubrication schedules.
To Next Page
Loading...
