GreenWorks CU800 - Periodic Service Schedule

GENERAL INFORMATION CU800 Service Manual
37
1.14.1 Periodic Service Schedule
REGULAR INTERVAL
SERVICE
Daily service by owner
Pre-Operation and Daily Safety Checklist
Performance Inspection
Batteries
Weekly service by
owner
Check the battery weekly, charge the battery in time
Monthly service by
owner or trained
technician
Check the battery monthly, charge the battery in time
Clean the surface of the battery
Check the wear and air pressure of the tire, and adjust or replace it if
necessary.
Thoroughly wash vehicle including the underside
Semiannual service by
trained technician only
(every 50 hours of
operation or 100
rounds of EV)
Check the Brake System.
Check brake shoes, replace if necessary
Lubricate brake system per Lubrication Schedule
Check brake cables; replace them if necessary
Electrical wires and connections: Check the tightness
and safety; Replace if necessary
Check the front wheel alignment and camber
Annual service by
trained
technician only (every
100
hours of operation or
200
rounds of EV)
Thoroughly check the battery, if one or some battery units are failed,
must change the full battery set.
Clean and lubricate all rotating joints
Check the frame, swing arm and replace the damaged parts, correct for
small deformation, painting make-up for rusting
Check and clean the rear axle, replace the damaged parts, and add the
required lubricants.