Miller Nitro 7310

To Next Page

To Previous Page

8-TROUBLESHOOTING

Whenadrivelinefaultispresentonthemachine,the

Faultsicon(1)willdisplayinred,andthe“Faults”mes-

sage(2)willbepresent.

Pressthefaulticon.TheWheelDriveFaultspagedis-

plays.

RAIL17SP01457AA9

TheWheelDriveFaultspagewilldisplaythefaultthatis

activeonthemachine.Takecorrectiveactionasrequired.

Pressthebackarrowbuttontoreturntotheprevious

screen.

RAIL17SP01458AA10

8-4

Main Page

Table of Contents2
General Information9
Your Sprayer9
Note to the Owner10
Intended Use11
Electro-Magnetic Compatibility (EMC)12
Product Identification13
Engine Serial Number13
Operator's Manual Storage on the Machine14
Machine Orientation15
Machine Components17
Selective Catalytic Reduction (SCR) System19
Safety Information25
Safety Rules and Signal Word Definitions25
Safety Rules26
General Safety Rules26
General Maintenance Safety27
Wheels and Tires27
Fire and Explosion Prevention28
General Battery Safety28
Operator Presence System29
Seat Belts29
Mounting and Dismounting31
Working at Heights31
Proposition 6532
Hand Signals33
Ecology and the Environment35
Battery Recycling35
Helpful Hints35
Emergency Exit Hammer36
Safety Rules - Boom Operation37
Boom Lift Cylinder Safety Stops38
Safety Signs39
Controls and Instruments55
Access to Operator's Platform55
Cab Entry and Exit55
Operator's Seat56
Control Identification - Luxury Cab57
Instructional Seat60
Forward Controls60
Steering Column60
Turn Signals61
Horn Button62
Floor Controls63
Brake Pedal63
Ventilation64
Right-Hand Side Controls67
Main Side Console67
Engine Speed Control69
Park Brake Switch70
Side Console80
Windshield Wiper Switch83
Windshield Washer Switch83
Joystick Control Handle86
Multi-Function Button96
Radio97
Radio Antenna97
Overhead Controls98
Front Sun Shade98
Exterior Controls98
Tank Fill Monitor (if Equipped)98
Exterior Remote Control Key Pad99
Auto-Rinse Display (if Equipped)104
Display107
Cab Mounted Displays107
Forward Overhead Display Panel107
A-Post Display109
Arm Rest Display113
Display Overview113
Climate Icons and Screens116
Auto Mode116
Product Icons and Screens117
Radio Mute Icon119
Camera Icon and Screens120
Tread Width (Manual) Icon and Screens121
Tread Width (Automatic) Icon and Screens122
Float Icon and Screens (if Equipped)123
Steering Icons and Screens (if Equipped)124
Arm Rest Display Second Home Screen125
Hydraulic Icon and Screens126
Electrical Icon and Screens127
Cooling Fan Icon and Screens129
Auto Steer Icon and Screens130
Engine Icon and Screens131
Suspension Icon and Screens135
Tire Size Icon and Screens138
Foamer Icon and Screens140
Driveline Icon and Screens142
Displays Icon and Screens145
Information Icon and Screens164
Cab Features165
Power Ports and Outlets165
Auxiliary Power Outlets166
USB Ports166
Operating Instructions167
Commissioning the Unit167
Before Starting the Engine167
Steering Column Adjustment169
Starting the Unit170
Normal Engine Starting170
Run-In Procedure170
Warm-Up Period171
Cold Temperature Operation172
Stopping the Unit173
Stopping the Engine173
Moving the Unit174
Battery Combiner176
Selective Catalytic Reduction (SCR) - Overview177
Diesel Exhaust Fluid (Def)/Adblue® Display Warnings180
Four Wheel Steer (4WS) if Equipped190
Operation Characteristics190
Steering Cylinder Phasing193
Parking the Unit196
Park Brake196
Transport Operations199
Road Transport199
Warning Lamps and SMV Symbol199
Safe Road Travel200
Shipping Transport201
Shipping on Trailer201
Tread Width Adjustment201
Recovery Transport205
Towing the Unit205
Working Operations207
General Information207
Axle Width Adjust207
Exterior Lights209
Rear Lights209
Boom Operation211
Right Side Primary Boom Swing In/Out - Mono Boom211
Right Side Secondary Boom Tip Fold In/Out - Mono Boom212
Left Side Primary Boom Swing In/Out - Mono Boom213
Left Side Secondary Boom Tip Fold In/Out - Mono Boom214
Right Side Primary Boom Swing In/Out - Truss Boom215
Right Side Secondary Boom Tip Fold In/Out - Truss Boom216
Left Side Primary Boom Swing In/Out - Truss Boom217
Left Side Secondary Boom Tip Fold In/Out - Truss Boom218
Spray System219
Spraying Safety Rules219
Control Valve Locations219
Bypass Valve221
Product Tank Sump Valve Switch223
Foam Marker System Overview (if Equipped)225
Pump Calibration229
Spray System Operation232
Tank Fill Monitor Operation (if Equipped)236
Home Screen236
Main Run Screen236
Information Screen237
Foam Marker Operation (if Equipped)238
Filling the Tanks241
Chemical Eductor Operation (if Equipped)245
Agitating the Product Tank250
Intellispray (Optional)251
Clean up at End of Operation256
Auto-Rinse Operation (if Equipped)257
Manual Mode257
Auto-Rinse Level Duration Setting275
Maintenance277
General Information277
Safety Rules277
Maintenance Advice278
Engine Compartment Access278
Engine Compartment Hood279
Windshield Washer Reservoir280
General Specification - Biodiesel Fuels281
General Specification - Diesel Fuel283
Fuel Conditioner283
Filling the Fuel Tank284
Fuel System Air Removal285
Filling the Diesel Exhaust Fluid (Def)/Adblue® Tank286
Tire and Rim Service288
Wheel Lug Nut Torque290
Hydraulic System291
Hydraulic System Cleanliness291
Propel System292
Auxiliary Circuit292
Pneumatic System (if Equipped)294
Air Compressor294
Fluids and Lubricants296
Engine Oils297
Engine Coolant System298
Surge Tank299
Organic Acid Technology (OAT) Coolant301
General Battery Maintenance302
Battery Terminals and Cables303
Battery Jump Starting Posts304
Battery Disconnect Switch305
Fuse Locations306
Maintenance Planning308
Maintenance Chart308
At Warning Message Display310
Fuel Filter/Water Separator310
Engine Coolant Level310
As Required312
Remove Trash/Debris from Chassis and Engine Area312
Clean the Cooling Package312
Cab Air Filters - Replace314
Flow Meter315
Flow Meter Sensor317
Flow Meter Calibration317
Flow Meter Cable318
Steam Clean the Engine319
Boom Cylinder Speed320
Boom Strainer Filters321
Hydraulic Oil Change and Oil Strainer Cleaning322
First 10 Hours323
Wheel Lug Nuts323
Every 10 Hours or Daily324
Check Engine Oil Level324
Check the Coolant Level324
Check the Hydraulic Oil Level325
Lubricate the Boom325
Lubricate the Steering King Pins334
Lubricate the Suspension Components335
Lubricate Ladder Pivot337
Fuel Filter Water Drain338
Check Engine Air Filters338
Air Intake - Check339
Cooling Fan340
Air Intake Lines340
SCR Exhaust Piping Connections341
Air Filter Dust Valve342
Remove Trash/Debris from Chassis and Engine Area342
First 50 Hours343
Wheel Lug Nuts343
Planetary Gear Lube - Change343
Every 50 Hours344
Foam Marker Mixing Filters and Screens344
Foamer Tank Filter344
Leg Widening Axle Slide Pads345
Planetary Hub Oil Level345
First 100 Hours346
Change Engine Oil and Filter346
Every 100 Hours348
Tire Pressure348
Primary Fuel Filter / Secondary Fuel Filter Replace348
Every 250 Hours350
Air Compressor Air Line (if Equipped)350
Air Intake - Check351
Replace the Air Filter Elements351
Charge Air Cooler353
Radiator Hoses353
Air Cleaner Restriction Indicator353
Cleaning the Radiators354
Hydrostat Filter Replacement355
Grease Engine Hood Pivots357
Every 400 Hours358
Replace Hydraulic Oil Filter358
Hydraulic Oil Breather Filter Element359
Every 500 Hours360
Change Engine Oil and Filter360
Primary Fuel Filter / Secondary Fuel Filter Replace360
Check the Battery and Cable Connection360
Radiator Surge Tank360
Planetary Gear Lube361
Once a Year362
Cab Air Filters - Replace362
Every 1000 Hours363
Change the Hydraulic Oil363
Serpentine Belt and Belt Tensioner Check364
Every Two Years365
Air Compressor Discharge Lines (if Equipped)365
Every 1800 Hours366
Change the Engine Breather Filter366
Every 3600 Hours366
Change the Def/Adblue® Supply Module Main Filter366
Every 4 Years367
Change the Engine Coolant367
Storage369
Storing the Machine369
Troubleshooting375
Fault Code Resolution375
Fault Code Retrieval375
Troubleshooting Procedures379
Symptom(S)379
Engine Troubleshooting379
Hydraulic System Troubleshooting380
Driveline Troubleshooting381
Foam Marker Troubleshooting386
Product Pump Troubleshooting387
Specifications389
General Specification - 7310389
10 - Accessories391
Portable Cooler391
Flashlight392
Toolbox393
Cellular Phone Holder (if Equipped)394
Pressure Washer (if Equipped)395
Crop Guide Bars (if Equipped)396
Boom Caster Wheel (if Equipped)397

Related product manuals

Miller Nitro 7380

392 pages

Miller NITRO 4000 Series

41 pages

Miller 500 BW

96 pages

Miller Nitro 7310 - Page 378

Table of Contents

Related product manuals