MR MSENSE DGA 9 - Table of Contents

MSENSE
®
DGA 9 7045899/02 EN – 11.2020 Page 3
List of contents
1. Introduction ................................................................................................................................ 6
Contact ................................................................................................................................. 6
Revision Rights ..................................................................................................................... 6
Completeness....................................................................................................................... 6
Legal provisions .................................................................................................................... 7
Safety Guidelines ................................................................................................................. 7
2. Safety .......................................................................................................................................... 8
Intended Use ........................................................................................................................ 8
Basic safety instructions ....................................................................................................... 8
Qualification of the staff ...................................................................................................... 10
Personal protective equipment ........................................................................................... 11
IT security ........................................................................................................................... 11
3. General information ................................................................................................................. 13
4. Mountinginstructions .............................................................................................................. 14
Installation position ............................................................................................................. 14
Safety notes on installation ................................................................................................. 15
Heating .................................................................................................................................. 15
Preparing installation .......................................................................................................... 18
4.3.1 Mechanical connection ................................................................................................ 18
4.3.1.1 Flange connection ................................................................................................ 18
4.3.1.2 Threaded joint ...................................................................................................... 18
4.3.2 Supply voltage connection ........................................................................................... 19
4.3.3 Tools required ............................................................................................................. 19
4.3.4 Sealing of the connecting thread ................................................................................. 19
4.3.4.1 Thread sealing tape .............................................................................................. 19
4.3.4.2 Thread adhesive ................................................................................................... 20
4.3.4.3 Flat gasket ............................................................................................................ 20
Installation .......................................................................................................................... 21
4.4.1 Mechanical installation ................................................................................................. 21
4.4.1.1 Direct mounting .................................................................................................... 21
4.4.1.2 Indirect mounting .................................................................................................. 38
4.4.2 Electrical connection .................................................................................................... 44
4.4.3 Initial start-up ............................................................................................................... 47
4.4.4 Turn off the device ....................................................................................................... 49
4.4.5 Automatic activation following the interruption of the supply voltage ............................ 50
5. Hardware components ............................................................................................................ 51
Internal front view with controls ........................................................................................... 51
View of rear ........................................................................................................................ 52
Connections for the measuring and controller card ............................................................. 54
5.3.1 Configuration of relay output 1 with coding bridge 1 (J1) ............................................. 58
Extraction menu ...................................................................................................... 65
5.4.1 Hardware components ................................................................................................. 65
6. Device firmware ....................................................................................................................... 68
General information ............................................................................................................ 68
6.1.1 Main screen ................................................................................................................. 68