Piper ARROW III - Page 82

TABLE III-I INSPECTION REPORT (cont)
Nature of Inspection
D. ENGINE GROUP (LYCOMING) (cont.)
48.Inspect condition and tension of alternator drive belt (Refer to Service Manual,
Section XI; XIV, if air conditioner is installed ....................................................... O O O
49.Inspect alternator idler pulley (if installed); remove front grease seal and add
grease. Refer to lubrication chart in Service Manual, Section II ............................ O O O
50.Inspect condition of alternator and starter ................................................................ O O O
51.Inspect security of alternator mounting ................................................................... O O O
52.Cheek air conditioner compressor oil level (Read Note 13)..................................... O O O
53.Inspect condition of compressor belt and tension (Refer to Service Manual, O O O
Section XIV)............................................................................................................. O O O
54.Inspect compressor clutch security and wiring ....................................................... O O O
55.Inspect security of compressor mounting................................................................. O O O
56.Check fluid in brake reservoir (Fill as required) ...................................................... O O O O
57.Lubricate all controls per lubrication chart in Service Manual, Section II............... O O O
58.Overhaul or replace propeller governor per manufacturer’s recommendations
(Read Note(s) 5 and 28)............................................................................................ O O O
59.Complete overhaul of engine or replace with factory rebuilt (Read Note(s) 5
and 28) ...................................................................................................................... O O O
60.Install the engine cowl.............................................................................................. O O O O
E. CABIN GROUP
WARNING
Read Note 28 before completing this inspection group.
1. Inspect cabin entrance door and windows for damage, operation, and security ...... O O O O
2. Inspect seats, seat belts, shoulder harness, security brackets and bolts (Read
Note 26) .................................................................................................................... O O O
3. Inspect trim operation............................................................................................... O O O
4. Inspect rudder pedals................................................................................................ O O O
5. Inspect parking brake and brake handle for operation and cylinder leaks................ O O O
6. Inspect control wheels, column, pulleys, chain, and cables (Read Note 23)............ O O O
7. Inspect flap control cable attachment bolt (See latest revision of Piper Service
Bulletin 965)............................................................................................................. O O O
8. Check landing, navigation, cabin, and instrument lights.......................................... O O O O
9. Inspect instruments, lines, and attachments ............................................................. O O O
10.Inspect gyro-operated instruments and electric turn and bank (Overhaul or
replace as required)................................................................................................... O O O
11.Replace instrument central air filter.......................................................................... O O O
12.Inspect or replace vacuum regulator filter................................................................ O O O
13.Check altimeter (Calibrate altimeter system in accordance with FAR 91.170,
if appropriate) (Read Note 11).................................................................................. O O O
50 500 1000100
Inspection Time (Hrs)
CHEROKEE ARROW III SERVICE MANUAL
1D10
Interim Revision: 2/21/95 INSPECTION