Quickie Groove User Manual

120©2006 Sunrise Medical
SEATING SECTION
Quickie Rhythm Service Manual Contents
VR2 Remote Controller ...................................0.3
VR2 Plugs/Connectors ....................................0.4
VR2 -Main Wiring Diagrams ............................0.5
R-NET Remote Controller ...............................0.7
R-NET Optional Electronics .............................0.9
R-NET Plugs/Connectors ..............................0.10
Main Wiring Diagram R-NET .........................0.12
Main Wiring Diagram R-net ...........................0.13
Section 1
Battery Connection Test ...................................1.1
Check Battery Wire Harness ............................1.2
Section 2
VR2 Remote Controller Display........................2.1
The Maximum Speed Indicator Ripples............2.1
The Maximum Speed Indicator Flashes ...........2.1
Battery Gauge is Steady...................................2.1
Battery Gauge Flashes Slowly .........................2.1
Battery Gauge Steps Up...................................2.1
Battery Gauge Blinks Once Every 2.5 Seconds
..........................................................................2.1
Battery Gauge Flashes Rapidly .......................2.1
VR 2 Remote & R-Net LED Controller Display .2.2
R-Net Color Joystick & OMNI Controller Display
Symbols ............................................................ 2.3
Section 3
VR2 Controller Diagnostic Codes .....................3.1
One Bar - Low Battery Voltage ) .......................3.1
Two Bars - Left Motor Disconnected ...............3.1
Three Bars - Left Motor Wiring Trip) .................3.2
Four Bars- Right Motor Disconnected ..............3.3
Five Bars - Right Motor Wiring Trip ..................3.4
Six Bars - Charger Connected..........................3.4
Seven Bars - Possible Joystick Trip ................3.4
Seven Bars + Speed Profile Indicator Communi-
cation Error ......................................................3.4
Eight Bars - Possible Control System Trip........3.5
Nine Bars - Solenoid Brake Trip .......................3.5
Ten Bars - High Battery Voltage ......................3.5
Section 4
R-net Troubleshooting Procedures ..................4.1
Chair Will Not Power Up ...................................4.1
Section 5
R-net Fault Codes ...........................................5.1
Power Chair Displays a Fault on the Hand Con-
trol or Omni .......................................................5.1
Table 1, Error Codes.........................................5.1
R-net Fault Codes cont.....................................5.3
Example of R-10 Fault Isolation .......................5.3
Power Chair Will Not Drive in Creep Speed when
Tilted .................................................................5.5
Tilt Will Not Operate .........................................5.6
Section 6
Troubleshooting Recline ..................................6.1
Power Chair Will Not Drive at Full Speed .........6.1
Troubleshooting Power Recline Calibration. ....6.2
Power Chair will not Drive in Creep Speed when
Reclined............................................................6.3
Power Recline does not Operate......................6.4
Power Shear Does not Operate .......................6.5
Section 7
Troubleshooting Power Legrest .......................7.1
Section 8
Seating System Mounting Instructions ............8.1
Non Tilt Module/Packer Interface .....................8.1
Seat to Tilt Mounting .........................................8.2
Seat to Tilt Mounting .........................................8.3
Tilt to Interface Mounting ..................................8.4
New Power Recline Seating System Mounting
Instructions ......................................................8.5
Seat to Recline Mounting .................................8.5
New Power Tilt & Recline Seating System Mount-
ing Instructions ................................................8.6
Seat to Tilt/Recline Mounting: ...........................8.6
Seat to Floor Height Matrix ...............................8.7
Asap Fixed Center mount Footrest Mounting Ma-
trix ................................................................... 8.10
Adjusting Power ELR / ALR Legrest Length ... 8.11
Adjusting Power Recline Backrest..................8.13
Section 9
OBP Programming Quick Guide ......................9.1

Quickie Groove Specifications

General

Brand	Quickie
Model	Groove
Category	Wheelchair
Language	English