Westerbeke W-27 - Page 105

DC ELECTRICAL SYSTEM
BT GENERATOR WIRING DIAGRAM #34651
® THIS PRODUCT /S PROTEC.TeD BY 8 I'1IUIIJflL ReSeT CIRcUIT 8REAKeR l.oCATC"D
NE:P.R THE 5TARTIERAND IlS CLoSE. TO ,HE SouRCE of cuRRS:NT Its PaSS/eLf:..
EXCESSive CURRENT DRAw IlNYWHERIE IN THI'!:. INSrRUI'1€.NT PANeL, WIRING OR
ENGINE WILL CAUsE THE. 8RI'!:.flKfiR To 'TRIP. IN 'TH/S eVENT MOST GENE:RRTOAS WILt
SHUT Do,,!'" SIE'CFHI$E T/-Ift OPENED l!3Fi'fiiAKeR DISCONN€C'TS THe: FUEL SUPPLY.
T/-IER€FOR€
THE aUIlDeR/OWNeR /'IVST BE SURE TI/AT THE /NSiRIJ/'1cI'lT PANEL
""IRING fiNO eNGINE. ARE INSTAI..I..E.D To PRE.VeNT CoNTACT I3E.Twlt/iiN
cl..E:C'TRICt1L DEVI(.ES AND SALT WfJ'TcR.
@ M05T STARTER SOLeNOIDS DRAW IS AMPS. THeREFORE 'THE VOl..1AGe DR'oF> IN TillS
CONcuCTOR NUST ae NO GREATeR rNfl" IO%.(IN Till! RqTH FROI1-THfi. STANDflRb
START SWITcH To fiN,! REMors: SWITCHeS liNt> BAC/< To Til;; Sf~NC>A~C> ST/iRTER S";IrCIf).
IF' THIS RE:~U/RE.$ JNPRIlCTICIILLY LARGe CONDUCTORS iI/eN A RelA'( M4Y Bt: ,qOPeO
To CONTROl.. Tlfe S1'IiRr€.R SOl.€No/t;J ITSlifLF.
============ OP ERA T 10 N
PRE-HEAT: DEPRESS PRE-HEAT SWITCH FOR 15 TO 60
--- SECONDS AS REQUIRED.
START:DEPRESS BOTH PRE-HEAT AND START SWITCHES
-- (PRE-HEAT ALSO OVERIDES LOI'I OIL PRESSURE
SHUTDOWN CIRCUIT).
WHEN GENERATOR STARTS RELEASE START
SWITCH ONLY_CONTINUe: HOLDING PRE-HEAT
SWITCH
FOR A FEW SECONDS (UNTIL OIL
PRESSURE REACHES 20 PSI).
STOP: DEPRESS STOP SWITCH UNTIL TH E GENERATOR
-- STOPS COMPLETELY.
@ WIRING SIZES TO REMOTE CONTROL PANEL
TERMINALS
a ,,,' IG-20'
20
25'
25 32'
32 'la'
40
so'
50-65'
TBI-I TO
T8,\-I "12
-1
,O
If',O
~9
#8 $7
~G
T91-2 TO
TB3-2
14
[2
12
10 10 9 8
TSh:, TO
T83-3 12 10 10
<;;1
8 7 6
T91-4 TO T93-4
16
16 16 16 16
16
16
TS2-1
To. T64-1 16 16
16
110
16 16
16
T82':.S TOT84-2
Ie
16 16 IG 16 16
16
Engines.& Generators
99