Yamaha F100B - Page 337

60C5D11
i-1
1
2
3
4
5
6
7
8
9
A.
Acceleration pump ....................................1-17
Adjusting the pilot screw ...........................4-19
Adjusting the throttle link rod.....................4-17
Adjusting the throttle position sensor ........4-18
Adjusting the trim sensor cam......... 7-28
,
7-68
After test run .............................................1-29
Applicable models.......................................1-5
Assembling the carburetor ........................4-17
Assembling the cylinder body ...................5-48
Assembling the drive shaft........................6-48
Assembling the drive shaft housing ..........6-20
Assembling the forward gear .......... 6-19
,
6-48
Assembling the fuel pump...........................4-8
Assembling the gear pump .......................7-84
Assembling the lower case ............. 6-19
,
6-47
Assembling the oil pan.................... 7-18
,
7-60
Assembling the oil pump................. 7-17
,
7-59
Assembling the power trim and tilt
motor............................................. 7-46
,
7-87
Assembling the propeller shaft
assembly....................................... 6-13
,
6-41
Assembling the propeller shaft
housing ......................................... 6-13
,
6-41
Assembling the pump housing..................7-40
Assembling the tilt cylinder .......................7-78
Assembling the tilt ram..............................7-35
Assembling the trim cylinder .....................7-76
Assembling the trim rams .........................7-33
B.
Backlash (F100B) .....................................6-29
Backlash (F100C) .....................................6-56
Bleeding the power trim and tilt unit
(F100B) ...................................................7-48
Bleeding the power trim and tilt unit
(F100C)...................................................7-88
Bottom cowling............................................7-9
Bracket unit ...............................................9-11
Bracket unit and the PTT unit ...................1-13
Break-in.....................................................1-29
Built-in ............................................. 7-52
,
7-89
C.
Carburetor....................................... 1-16
,
4-13
Changing the engine oil ..............................3-5
Changing the gear oil................................3-13
Charging system .......................................8-20
Checking the anodes ................................3-14
Checking the armature..............................8-17
Checking the battery ....................... 1-26
,
3-15
Checking the bearings .................... 6-18
,
6-46
Checking the brushes............................... 8-18
Checking the camshaft ............................. 5-31
Checking the carburetor ........................... 4-15
Checking the CDI unit................................. 8-9
Checking the check valve......................... 4-15
Checking the compression pressure .......... 5-9
Checking the cooling water passage.......... 3-8
Checking the crankshaft ........................... 5-42
Checking the crankshaft main journal oil
clearance ................................................ 5-45
Checking the crankshaft pin oil
clearance ................................................ 5-43
Checking the cylinder bore ....................... 5-40
Checking the cylinder head ...................... 5-32
Checking the diaphragm and valves .......... 4-8
Checking the drive shaft ..................6-18
,
6-46
Checking the electrical components........... 8-2
Checking the engine idle speed ............... 3-10
Checking the engine oil .....................1-26
,
3-5
Checking the engine shut-off switch......... 8-12
Checking the engine start switch.............. 8-12
Checking the engine start switch and
engine stop switch/engine shut-off
switch...................................................... 1-28
Checking the filters ..........................7-39
,
7-84
Checking the fuel filter ................................ 3-4
Checking the fuel filters ............................ 4-15
Checking the fuel joint and fuel hoses
(fuel joint-to-carburetor) ............................ 3-4
Checking the fuel pump.............................. 4-7
Checking the fuel system ......................... 1-25
Checking the fuse............................7-91
,
8-14
Checking the gear oil................................ 1-26
Checking the gear oil level ....................... 3-13
Checking the gear pump .................7-40
,
7-84
Checking the gearshift and throttle
operation................................................. 1-27
Checking the gearshift operation.............. 3-10
Checking the high-tension cords ................ 8-8
Checking the hour meter ............................ 3-4
Checking the hydraulic pressure .............. 7-49
Checking the ignition coil............................ 8-9
Checking the ignition spark gap ................. 8-8
Checking the ignition timing...................... 3-11
Checking the lighting coil.......................... 8-21
Checking the lower case .................6-19
,
6-47
Checking the lower unit (for air leakage) .. 3-14
Checking the neutral switch...................... 8-14
Checking the oil pressure ........................... 5-9
Checking the oil pressure switch .............. 8-11
Checking the oil pump .....................7-17
,
7-59
Checking the oil strainer ..................7-18
,
7-60