Yamaha F100B - Page 338

Index
i-2
60C5D11
Checking the outboard motor mounting
position....................................................1-26
Checking the pilot water outlet..................1-28
Checking the pinion and forward
gear............................................... 6-18
,
6-46
Checking the piston clearance..................5-41
Checking the piston diameter ...................5-40
Checking the piston ring grooves..............5-42
Checking the piston ring side clearance ...5-42
Checking the piston rings..........................5-41
Checking the power trim and tilt fluid
level.........................................................3-12
Checking the power trim and tilt
motor............................................. 7-45
,
7-87
Checking the power trim and tilt
operation .................................................3-12
Checking the power trim and tilt relay.......7-91
Checking the power trim and tilt
switch/trailer switch .................................7-91
Checking the Prime Start ..........................4-16
Checking the propeller ..............................3-14
Checking the propeller shaft ........... 6-13
,
6-40
Checking the propeller shaft
housing ......................................... 6-12
,
6-40
Checking the pulser coil............................8-10
Checking the Rectifier Regulator ..............8-21
Checking the relay assembly ....................8-19
Checking the remote control cables..........1-27
Checking the reservoir ..............................7-33
Checking the spark plugs............................3-7
Checking the starter motor operation........8-19
Checking the starter motor pinion .............8-17
Checking the starter relay .........................8-14
Checking the steering system...................1-27
Checking the thermo sensor .....................8-11
Checking the thermostat .............................3-8
Checking the throttle cable operation .........3-9
Checking the throttle position sensor........8-10
Checking the tilt cylinder and trim
cylinder.......................................... 7-33
,
7-75
Checking the tilt system ............................1-28
Checking the timing belt..............................3-7
Checking the timing belt and sprockets ....5-18
Checking the top cowling ............................3-4
Checking the trim sensor ..........................7-91
Checking the valve clearance ............. 3-7
,
5-6
Checking the valve guides ........................5-27
Checking the valve seat............................5-28
Checking the valve springs .......................5-26
Checking the valves...............5-26
,
7-39
,
7-83
Checking the water pump and
shift rod ........................................... 6-8
,
6-36
Checking the wiring harness (10 pins)......8-14
Clamp brackets (F100B)........................... 7-25
Clamp brackets (F100C) .......................... 7-65
Control system............................................ 3-9
Cooling system ................................1-14
,
1-21
Cylinder body............................................ 5-36
Cylinder head ........................................... 5-21
D.
Dimensions................................................. 2-9
Disassembling the cylinder body .............. 5-39
Disassembling the drive shaft................... 6-45
Disassembling the drive shaft housing ..... 6-17
Disassembling the forward gear ......6-17
,
6-45
Disassembling the fuel pump ..................... 4-8
Disassembling the gear pump .........7-39
,
7-83
Disassembling the lower case .........6-18
,
6-46
Disassembling the oil pan................7-18
,
7-60
Disassembling the oil pump.............7-17
,
7-59
Disassembling the power trim and tilt
motor ...................................................... 7-44
Disassembling the propeller shaft
assembly .......................................6-12
,
6-40
Disassembling the propeller shaft
housing ..........................................6-11
,
6-39
Disassembling the tilt cylinder .................. 7-75
Disassembling the tilt cylinder and trim
cylinders ................................................. 7-32
Disassembling the trim cylinder................ 7-75
Disassembly and assembly ........................ 1-4
Drive shaft and lower case (F100B) ......... 6-15
Drive shaft and lower case (F100C) ......... 6-43
E.
Electrical ..................................................... 2-7
Electrical components ................................ 8-3
Electrical systems..................................... 9-15
F.
Features and benefits................................. 1-6
Fire prevention............................................ 1-3
Front and rear views................................... 8-4
Fuel line and fuel filter ................................ 4-3
Fuel pump................................................... 4-5
Fuel system ................................................ 3-4
Fuel, blowby, and cooling water hoses....... 4-2
G.
Gear pump (F100B).................................. 7-37
Gear pump (F100C) ................................. 7-80
General..................................................... 3-14
General specifications ................................ 2-1
General torques........................................ 2-16