Beta Ark AC User Manual

GENERAL INDEX
FAILURES CHARACTERISTICS
- Safety regulations . . . . . . . . . . . . . . . . . . . . . . . . Pag. 1-1
- Maintenance regulations . . . . . . . . . . . . . . . . . . . Pag. 1-1
- Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . Pag. 1-3
- Recommended products table . . . . . . . . . . . . . . . . Pag. 1-7
- Driving torques table . . . . . . . . . . . . . . . . . . . . . . Pag. 1-7
- Maintenance and troubleshooting (cause and remedy) Pag. 1-8
- Air cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Pag. 1-27
- Carburetor disassembly . . . . . . . . . . . . . . . . . . . . Pag. 1-28
- Carburetor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Pag. 1-29
Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Pag. 1-29
- Carburetor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Pag. 1-30
Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Pag. 1-30
- Spark plug disassembly . . . . . . . . . . . . . . . . . . . Pag. 1-31
- Headlight adjustment . . . . . . . . . . . . . . . . . . . . . Pag. 1-31
- Key switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . Pag. 1-32
- Muffler disassembly . . . . . . . . . . . . . . . . . . . . . . Pag. 1-32
- Oil replacement in the gearcase . . . . . . . . . . . . . . Pag. 1-33
- Removing engine from frame . . . . . . . . . . . . . . . . Pag. 1-34
- Disassembly of liquid temperature bulb . . . . . . . . . Pag. 1-35
- Radiator disassembly . . . . . . . . . . . . . . . . . . . . . Pag. 1-35
- Radiator’s support disassembly . . . . . . . . . . . . . . Pag. 1-36
- Horn disassembly . . . . . . . . . . . . . . . . . . . . . . . Pag. 1-36
LIGHTING SET
- Lighting equipment . . . . . . . . . . . . . . . . . . . . . . . Pag. 2-1
- Electrical equipment . . . . . . . . . . . . . . . . . . . . . . Pag. 2-6
- Controls to be carried out in case of igntion troubles Pag. 2-8
- Voltage regulator . . . . . . . . . . . . . . . . . . . . . . . . Pag. 2-8
- Checking battery recharge . . . . . . . . . . . . . . . . . . Pag. 2-12
- Starting motor . . . . . . . . . . . . . . . . . . . . . . . . . . Pag. 2-12
- Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Pag. 2-13
SUSPENSIONS
- Handlebar disassembly . . . . . . . . . . . . . . . . . . . . Pag. 3-1
- Steering tube disassembly . . . . . . . . . . . . . . . . . . Pag. 3-2
- Grommet and stem disassembly . . . . . . . . . . . . . . Pag. 3-3
- Stand disassembly . . . . . . . . . . . . . . . . . . . . . . . Pag. 3-4
- Steering’s lower and upper seat . . . . . . . . . . . . . . Pag. 3-5
- Handlebar assembly . . . . . . . . . . . . . . . . . . . . . . Pag. 3-6
- Front wheel axle disassembly . . . . . . . . . . . . . . . . Pag. 3-6
- Rear wheel disassembly . . . . . . . . . . . . . . . . . . . Pag. 3-7
- Ball bearing on front wheel hub . . . . . . . . . . . . . . Pag. 3-7
- Shock absorber . . . . . . . . . . . . . . . . . . . . . . . . . . Pag. 3-8
- Shock absorber adjustment . . . . . . . . . . . . . . . . . .Pag. 3-9
BRAKING SYSTEM
- Front and rear brake pads replacement . . . . . . . . . Pag. 4-1
- Replacement of front and rear brake caliper . . . . . . Pag. 4-2
- Checking brake disk integrity . . . . . . . . . . . . . . . . Pag. 4-3
- Checking brake disk deformation . . . . . . . . . . . . . Pag. 4-3
- Brake disk replacement . . . . . . . . . . . . . . . . . . . Pag. 4-4
- Brake pump replacement . . . . . . . . . . . . . . . . . . . Pag. 4-5
- Rear brake shoes replacement . . . . . . . . . . . . . . . Pag. 4-6
- Oil introduction and braking system bleeding . . . . . Pag. 4-7
BODYWORK
- Saddle disassembly . . . . . . . . . . . . . . . . . . . . . . Pag. 5-1
- Tail disassembly . . . . . . . . . . . . . . . . . . . . . . . . Pag. 5-1
- Plate carrier disassembly . . . . . . . . . . . . . . . . . . . Pag. 5-2
- Tail end disassembly . . . . . . . . . . . . . . . . . . . . . Pag. 5-2
- Rear indicators disassembly . . . . . . . . . . . . . . . . . Pag. 5-3
- Battery cover disassembly . . . . . . . . . . . . . . . . . . Pag. 5-3
- Right and left body side disassembly . . . . . . . . . . . Pag. 5-4
- Helmet compartment disassembly . . . . . . . . . . . . . Pag. 5-4
- Removal of front indicators transparent cover . . . . . Pag. 5-5
- Front handlebar cover disassembly . . . . . . . . . . . . Pag. 5-5
- Rear handlebar cover disassembly . . . . . . . . . . . . Pag. 5-6
- Legs guard disassembly . . . . . . . . . . . . . . . . . . . . Pag. 5-6
- Footrest disassembly . . . . . . . . . . . . . . . . . . . . . Pag. 5-7
- Sprag disassembly . . . . . . . . . . . . . . . . . . . . . . . Pag. 5-7
- Splash guard disassembly . . . . . . . . . . . . . . . . . . Pag. 5-8
- Splash guard disk disassembly . . . . . . . . . . . . . . . Pag. 5-8
- Conveyors disassembly . . . . . . . . . . . . . . . . . . . . Pag. 5-9
- Front shield disassembly . . . . . . . . . . . . . . . . . . . Pag. 5-9
- Front grill disassembly . . . . . . . . . . . . . . . . . . . . .Pag. 5-10
- Front indicator disassembly . . . . . . . . . . . . . . . . . Pag. 5-10
- Front optical unit disassembly . . . . . . . . . . . . . . . .Pag. 5-11
- Rear optical unit disassembly . . . . . . . . . . . . . . . . Pag. 5-11
- Recovery tank disassembly . . . . . . . . . . . . . . . . . . Pag. 5-12
- Oil tank disassembly . . . . . . . . . . . . . . . . . . . . . Pag. 5-12
- Fuel tank disassembly . . . . . . . . . . . . . . . . . . . . . .Pag. 5-13
- Rear mudguard disassembly . . . . . . . . . . . . . . . . Pag. 5-13
- Hands guard disassembly . . . . . . . . . . . . . . . . . . Pag. 5-14
- Intrumentation lamps disassembly . . . . . . . . . . . . Pag. 5-14
- Headlight lamps replacement . . . . . . . . . . . . . . . . Pag. 5-15
- Rear lamp replacement . . . . . . . . . . . . . . . . . . . . Pag. 5-15

Beta Ark AC Specifications

General

Brand	Beta
Model	Ark AC
Category	Motorcycle
Language	English