Maintenance – Planned maintenance
10-03-2022 4812331840EN 81
Every 1000 hours of operation (Every six months)
Refer to the contents to find the page
number of the sections referred to !
Pos. in
Action Comment
4
Replace the air cleaner's main filter and
backup filter
7 Change the hydraulic fluid filter
8 Drain the condensate from hydraulic reservoir
25 Drain condensate from fuel tank
21 Change oil in rear axle differential
22 Change oil in the rear axle planetary gearing
Check engine valve clearances Refer to the engine manual
32 Check belt tension for Engine drive system Refer to the engine manual
3 Change the Engine Oil & Oil filter Refer to the engine manual
2 Change the Fuel filter & pre fuel filter Refer to the engine manual
Change the water separator Refer to the engine manual
17 Steering Hitch tightening
14
Cleaning the ventilation screws in the drum
cartridges
Every 2000 hours of operation (Yearly)
Refer to the contents to find the page number of
the sections referred to !
Pos. in fig Action Comment
8, 9 Change the hydraulic fluid
11 Change the oil in the drum
33 Lubricate the Forward/Reverse lever
Overhaul air conditioning Optional
Change the Engine Oil & Oil filter Refer to the engine manual
Change the Fuel filter & Pre fuel filter Refer to the engine manual
Change the water separator Refer to the engine manual
Change the oil in the Drum Gear box Applicable to CA25D and
CA30D
No need to change oil in CA35D
To Next Page
Loading...
Need help?
General
