Evector SportStar RTC - Chapter 05 Time Limits; Maintenance Checks; Table of Contents

MAINTENANCE MANUAL
ERTC022-10-AS
Effectivity: All
05-TOC
Page 05-1
2019-03-22
Issue 2 | Rev. 1
CHAPTER 05
TIME LIMITS / MAINTENANCE CHECKS
TABLE OF CONTENTS
Title Section Page
General ...................................................................................................................... 05-00 ...................... 05-3
1. Introduction ................................................................................................................................. 05-3
2. Definitions ................................................................................................................................... 05-3
Time limits / Inspection program ............................................................................ 05-10 ...................... 05-5
1. Inspection requirements .............................................................................................................. 05-5
2. Inspection program ..................................................................................................................... 05-5
A. Airplane flown less than 100 flight hours per year ............................................................... 05-5
B. Influence of environmental condition (abnormal conditions) ............................................... 05-5
3. Service bulletins .......................................................................................................................... 05-6
A. Mandatory Service Bulletin (“Safety Related”) .................................................................... 05-6
B. Service Bulletin .................................................................................................................... 05-6
C. Notification Bulletin .............................................................................................................. 05-6
4. Publications, references .............................................................................................................. 05-6
Scheduled maintenance .......................................................................................... 05-20 ...................... 05-7
1. Responsibility of owner or operator ............................................................................................ 05-7
2. Inspection minimum requirements .............................................................................................. 05-7
3. Inspection tolerances .................................................................................................................. 05-7
4. Inspection intervals ..................................................................................................................... 05-9
5. Engine inspections ...................................................................................................................... 05-9
6. Propeller inspections ................................................................................................................... 05-9
A. Klassic 170/3/R propeller inspections .................................................................................. 05-9
B. KW-31-033 propeller inspections ......................................................................................... 05-9
7. Inspections of parts – general ................................................................................................... 05-10
8. Inspection guidelines................................................................................................................. 05-10
Scheduled special maintenance checks ................................................................ 05-30 .................... 05-23
1. Scheduled special maintenance checks requirements ............................................................. 05-23
2. Influence of environmental conditions (abnormal conditions) ................................................... 05-23
3. Scheduled special maintenance checks tolerances ................................................................. 05-23
Unscheduled maintenance checks ......................................................................... 05-50 .................... 05-31
1. General ..................................................................................................................................... 05-31
2. Hard landing .............................................................................................................................. 05-32
3. Exceeding of load factors / flight in severe turbulence .............................................................. 05-35
4. Ground gust .............................................................................................................................. 05-38
5. Lightning strike .......................................................................................................................... 05-40