Home
Pitco
Fryer
SSH Series
Pitco SSH Series User Manual
5
of 1
of 1 rating
94 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
Pitco
Solstice
and
Solstice
Supreme
High
Efficiency
Gas
Fryers
SG/SSH
Series
Service
Manu
al
32
6.
Remove the fittings and plate from the gas valve
using a 7/16 inch open-ended wrench.
7.
Install the heat shield, vent tube, and fittings.
8.
Reinstall a new gas valve by following steps 1
through 6 in reverse.
31
33
Table of Contents
Default Chapter
3
Table of Contents
3
Theory of Operation
6
Fryer Components Operation
7
Heating System
7
Safety System
8
Filter System
8
Optional Basket Lift
8
Controller Operational Modes
9
Serial Numbers
10
24V Model
11
Accessing Fryer for Servicing
12
Cleaning the Gas Valve Vent Tube
13
Checking the Burner Manifold Gas Pressure
14
Taking a Supply Gas Pressure Reading
14
Removing Solid State Thermostat (if Necessary)
16
Taking a Manifold Gas Pressure Reading
17
Adjusting Manifold Gas Pressure
18
Adjusting Pilot Pressure
18
Calibrating Solid State Thermostat
19
Replacing the Controllers and Wiring Harness
20
Removing the Controller Front Panel Bezel
20
Removing the Solid State Wiring Harness
21
Replacing the Relay Board and Paper
23
Replacing the Ignition Module
24
Replacing the Spinal Tap
25
Replacing an Igniter/Pilot Assembly
28
Replacing the Self-Cleaning Burner Solenoid
30
Replacing the Gas Valve
31
Replacing the Transformer Box
33
Replacing the DVI Switch
35
Replacing the Burner Assembly
36
Replacing the Burner(S)
36
Replacing the Burner Assembly
38
Replacing the Frypot
40
Replacing the Basket Lift Components
44
Removing the Basket Lift Cover
44
Replacing the Transformer
44
Replacing the Basket Lift Driver Board
45
Adjusting the Magnetic Sensor
46
Replacing the Basket Lift Actuator
46
Gas Conversion
49
MV Model
50
Accessing Fryer for Servicing
51
Cleaning the Gas Valve Vent Tube
51
Checking the Burner Manifold Gas Pressure
51
Taking an Incoming Supply Gas Pressure Reading
51
Taking a Manifold Gas Pressure Reading
52
Adjusting Manifold Gas Pressure
53
Measuring Thermopile
54
Taking a Millivolt Reading
54
Adjusting the Thermopile
54
Replacing the Thermostat
55
Calibrating the Thermostat
57
Replacing the Hi-Limit Thermostat
58
Filter System
59
Replacing the Return Valve
60
Replacing the Flush Hose Assembly and Valve
61
Replacing the Heat Tape
64
Replacing the Waste Oil and Components
65
Removing Rear Mounting Bracket
65
Removing the Check Valve
66
Replacing the Filter Pump and Motor
68
Removing the Filter Pump and Motor
68
Replacing Seal Kit
70
Removing the Filter Pump from the Motor
71
Replacing the Return Switch
72
Replacing the Drain Line or Gasket
74
Replacing the Pump Relay and Circuit Breaker
75
Replacing the Circuit Breaker
75
Replacing the Pump Relay
76
Troubleshooting and Problem Isolation
77
Troubleshooting and Problem Isolation
78
Interpretation of Solid State Controller Lights
78
Solid State Thermostat Field Calibration
79
Component Troubleshooting
80
Probe
80
Roll out Switch
80
Gas Valve
80
Hi-Limit
80
Drain Valve and Return Valve Switches
81
Transformer
81
Ignition Module
81
Relay Board
82
Computer Control
82
Digital Solid State Control
83
Primary Solid State Control
83
Backup Solid State Control
84
Optional Basket Lift
84
Probe Resistance Chart
85
Orifice Size Chart
86
Orifice Size at Sea Level Chart
87
Wiring Diagrams
88
Simplified Wiring Diagrams
89
Wiring Diagram - Full Vat with SCB
89
Wiring Diagram - Twin Vat with SCB
90
Wiring Diagram - Basket Lifts
91
Wiring Diagram - Filter Motor 115V-60Hz
92
Wiring Diagrams - Filter Motor 208-240V
93
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Pitco SSH Series and is the answer not in the manual?
Ask a question
Pitco SSH Series Specifications
General
Brand
Pitco
Model
SSH Series
Category
Fryer
Language
English
Related product manuals
Pitco SSHLV14 Series
38 pages
Pitco SSHLV184 Series
38 pages
Pitco SG
48 pages
Pitco SE14
2 pages
Pitco SG6H
32 pages
Pitco SGH50
36 pages
Pitco SEH50
40 pages
Pitco SE Series
16 pages
Pitco SGH50 Full
32 pages
Pitco 7
48 pages
Pitco 35C+
41 pages
Pitco L22-355
28 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
