Avid Technology MV3000 DELTA - Table of Contents; Contents

T1689 Technical Manual Rev 07
MV3000 Air Cooled DELTA
Page 7
CONTENTS
DEFINITIONS ............................................................................................................................................. 2
SAFETY INSTRUCTIONS .............................................................................................................................. 3
WARNINGS, CAUTIONS & NOTES .............................................................................................................. 3
UNITS COVERED ........................................................................................................................................ 4
CONTENTS ................................................................................................................................................ 7
1. INTRODUCTION ............................................................................................................................... 13
1.1 GENERAL DESCRIPTION ................................................................................................................. 13
1.1.1 Advantages Of The Modular System ...................................................................................... 13
1.1.2 DELTA Product Range ............................................................................................................. 13
1.2 ASSOCIATED MANUALS ................................................................................................................ 14
1.3 ABOUT THIS MANUAL ................................................................................................................... 15
1.4 DRIVE CONFIGURATIONS .............................................................................................................. 16
1.4.1 DFE Network Bridge ............................................................................................................... 17
1.4.2 Sinusoidal Front End (AEM Network Bridge) .......................................................................... 17
1.4.3 Machine Bridge ...................................................................................................................... 17
1.5 TYPICAL LAYOUT OF KEY DELTA COMPONENTS ........................................................................... 18
2. SPECIFICATION ................................................................................................................................ 21
2.1 INTRODUCTION ............................................................................................................................. 21
2.2 DELTA COMPONENTS (GENERAL ENVIRONMENT) ....................................................................... 21
2.2.1 Electrical Supply ..................................................................................................................... 21
2.2.2 Switching Frequency .............................................................................................................. 22
2.2.3 Temperature & Humidity ....................................................................................................... 22
2.2.4 Ingress Protection................................................................................................................... 23
2.2.5 Vibration ................................................................................................................................. 23
2.2.6 Inclination ............................................................................................................................... 24
2.3 DRIVE PERFORMANCE WITH MV3000E CONTROLLER .................................................................. 24
2.4 MV3000E CONTROLLER ................................................................................................................ 25
2
.4.1 Electrical Connections ............................................................................................................ 26
2.4.2 Weight .................................................................................................................................... 27
2.4.3 Optional Modules ................................................................................................................... 27
2.5 USER I/O TERMINATION PANEL .................................................................................................... 27
2.5.1 Electrical Connections ............................................................................................................ 28
2.5.2 Weight .................................................................................................................................... 29
2.6 MAINS VOLTAGE MONITOR (MVM) ............................................................................................. 30
2.6.1 Electrical Connections ............................................................................................................ 30
2.6.2 Weight .................................................................................................................................... 30
2.7 SWITCHED MODE POWER SUPPLIES (SMPS) ................................................................................ 31
2.7.1 Electrical Connections ............................................................................................................ 32
2.8 MV3000E DRIVE DATA MANAGER
TM
(KEYPAD) ............................................................................. 32
2.9 DELTA RECTIFIER MODULE ........................................................................................................... 33
2.9.1 DELTA Rectifier Type MVR ...................................................................................................... 34
2.9.2 DELTA Rectifier Type GDR ...................................................................................................... 40
2.10 DELTA TRANSISTOR MODULE ....................................................................................................... 54
2.10.1 Features .................................................................................................................................. 55
2.10.2 Interfaces ................................................................................................................................ 55
2.10.3 External Requirements ........................................................................................................... 55
2.10.4 A.C. Phase Current Ratings ..................................................................................................... 55
2.10.5 Phase Voltage ......................................................................................................................... 56
2.10.6 D.C. Link Voltage ..................................................................................................................... 56