245
20 08 CONTESSA
CHASSIS INFORMATION — 10
NOTE:
Service must be performed every twelve (12) months, regardless of actual mileage, to protect seals, bearings and gaskets from drying out
and failing. The motorhome must be started and driven for at least 20 miles every two weeks. It is important to remember the generator
maintenance interval is based on hours of usage. Consult the OEM Owner’s Manual for the generator service interval.
COMPONENT: ACTION: WHEN: CODE:
1 Engine Oil Fill Keep to full mark Before each trip/daily en route EO
2 Engine Oil Filter Replace At Oil Change OEM
3
Transmission Keep to full mark Refer to OEM Manual TS
4 Engine Coolant Reservoir Maintain level Before each trip OEM
5a Hydraulic Filter Reservoir Replace 15,000 or annually -
5b Hydraulic Filter Replace Monitor Gauge -
6 Primary Fuel Filter Replace 15,000 miles or 6 months FF
7 Secondary Fuel Filter Replace Refer to OEM manual OEM
8 Air Dryer Filter Replace 2-3 Years -
9 Radiator/Charge Air Cooler Inspect Weekly -
10 Wheel Bearings Re-pack 30,000 miles or annually HT
11 Rear Differential Replace Fluid 250,000 miles or 3 years MP
12 Slack Adjuster/S-cams Grease 3 ttings each 10,000 or 3 months CL
13 Drive Shaft Universal Joints Grease 2 ttings 5,000 or 6 months CL
14 Drive Shaft Slip Yoke Grease 1 tting 5,000 or 6 months CL
15 Drag Link Grease 2 ttings 5,000 or 6 months CL
16 Center Link Grease 2 ttings 5,000 or 6 months CL
17 Spindles/Kingpins Grease 2 ttings 5,000 or 6 months CL
18 Intermediate Steering Shaft Grease 3 ttings 30,000 or annually CL
19 Air Tank Drains Drain Monthly -
20 Hydraulic Jacks Reservoir Keep to full mark 6,000 or 3 months HF
21 Tire Pressure Check Before each trip -
22 Steering Box Grease 1 tting Every 6 months CL
23 Generator Refer to OEM Manual Refer to OEM Manual OEM
24 Batteries
Inspect
Apply Coating
Every Two Weeks
10,000 miles or quarterly
DW
P
25 Air Filter Minder Inspect -- -
26 Slide-room Reservoir Keep to full mark 3 months HF
Lubrication Code Chart:
*EO
Engine oil as recommended by
engine manufacturer. Texaco URSA
Super Plus SAE 15W-40.
*OEM
Refer to the Original Equipment
Manufacturer’s manual.
*MP
API GL-5 or MT-1 type gear
lubricant - Texaco Star Gear SAE
80W-90 Non-Synthetic.
*CL
Chassis lubricant should be a high
quality non corrosive multi-purpose
lithium soap base lubricant that is
water resistant and designed to
withstand extremely high operating
temperatures. Texaco Starplex
NLGI 2.
*AF
Antifreeze as recommended by
engine manufacturer. Texaco 50/50
with bitterant and SCA.
*BF Dot-3 Brake Fluid
FF Fuel Filter
HT High Temperature Bearing Grease
*TS TranSynd™
DW Distilled Water
*HF
Texaco Rando HD46 Hydraulic
Fluid
P
Petroleum Jelly
* Fluids initially lled at factory.
To Next Page
Loading...