5 Maintenance
Inspection and maintenance overview
Inspection and maintenance overview
Service plan as required
Carried
out
9
8
Engine
Clean the fuel tank venti
lation hose
Drain water from the fue
lfilter
Change the air filter cartridge (after no longer than 1000 operating hours)
Change the safety cartridge in the air filter (after no longer than 3000 operating
hours)
Check the dust discharge valve
Change the oil bath air filter oil
Clean the prefilter
Clean the water cooler and hydraulic oil cooler, and check them for leaks
Regenerate the particle filter
Drain water from the water trap at the changing particle filter
Chassis, bodywork and fittings
Clean the truck
Service the heating system and air conditioning
Check condition and correct operation of the seat belt
Washer sy
stem: Top up the water tank
Chassis frame
Wheel ch
ange
Clean and grease the steering axle (after no longer than 1000 operating hours)
Check tyres for damage and foreign bodies
Tighten wheel fastenings (after each maintenance or repair, after no longer than
100 operating hours)
Load
lift system
Cle
an and adjust the lift mast chain and apply chain spray.
Cle
an and grease the sideshift, check the mounting
108 Operating Instructions – 394 807 10 01 EN – 07/2011
To Next Page
Loading...
