NMC-WOLLARD 2021Truax Blvd., Eau Claire, WI 54703, Phone (715) 835-3151, Fax (715) 835-6625
M140 Tow Tractor Manual No. 46054
PAGE 1-11
CHAPTER 2 MAINTENANCE
1 SERVICING
AUGUST 31, 2008
1.4.6 Instructions For Cleaning Spark Arrester/Exhaust System
1. Disposal of accumulated particles may be accomplished by following the
steps listed below.
2. IN A SAFE AREA take precautions to collect and properly dispose of
residue falling from the spark arrester trap.
drainage. Exposure to this drainage can result in serious injury.
1. Remove the plug (pipe plug) on the bottom half or side of the spark
mixed with condensation or other oily liquids may also empty out.
2. Without causing deformation (or any type of damage to the spark arrester)
repeatedly tap on the arrester near the plug. This may be enough to begin
drainage of the spark trap.
3. An industrial vacuum cleaners can do a complete job at this point. IN
A SAFE AREA, start the engine. Idle in a neutral gear. Then alternate
between low idle and high idle for two to three minutes. You can also
operate the engine while doing two to three minutes of work.
4. If the engine was started, TURN OFF THE ENGINE AND LET THE
ARRESTER COOL AGAIN, as stated above.
5. Replace the cleanout plug.
6. Dispose of the accumulated particles.
NOTICE! This maintenance is recommended after every 250 hours of use.
If any breaks in the metal or are discovered, the spark arrester must be
replaced.
1.4.7 Batteries
servicing safety precautions:
• Sulfuric battery acid is poisonous. Avoid breathing battery fumes.
• Battery acid is strong enough to burn skin and cause blindness if splashed
into the eyes. Protect eyes and skin from contact. In the event of contact
with battery acid, immediately rinse in large amounts of water. Obtain
medical care if the eyes are burned.
•
To Next Page
Loading...
