5-1
764332-098
5.1 TROUBLESHOOTING
WARNING – PERSONAL INJURY AND/OR
EQUIPMENT DAMAGE HAZARD: Only
STERIS or STERIS-trained service technicians
should make repairs and adjustments to this
equipment. Maintenance done by inexperienced,
unqualified personnel or installation of unautho-
rized parts could cause personal injury, invalidate
warranty or result in costly damage. Contact
STERIS regarding service options.
WARNING – ELECTRIC SHOCK AND/OR
BURN HAZARD:
• Fasteners and star washers are used to
ensure protective bonding continuity. Always
reinstall any star washer which may have been
removed during installation or servicing.
• Disconnect all utilities to unit before servicing.
Do not service unit unless all utilities have
been properly locked out. Always follow local
electrical codes and safety-related work prac-
tices.
WARNING – SLIPPING HAZARD: To prevent
slips, keep floor dry. Promptly clean up any
spills or condensation. If spilled liquids are deter-
gents or other chemicals, follow safety precau-
tions and handling procedures set forth on deter-
gent or chemical label/or Material Safety Data
Sheet (MSDS).
This section contains detailed information on the types
of washer malfunctions likely to occur, and possible
causes and corrective actions.
If you are unable to correct the problem with use of the
following Troubleshooting Charts, or if a problem
occurs that is not described on the chart, please call
STERIS. A factory-trained technician will promptly
place your washer in proper working condition.
NOTE: Never permit unqualified persons to service the
washer.
Table Descriptions
Table 5-1 – Troubleshooting Chart - Situations where
NO Alarm or Printout occur.
Table 5-2 – Fault Chart - Faults where alarm and/or
printout occur.
IMPORTANT: A listing of the Safety Precautions to be observed when operating and servicing this Cage
and Rack Washer can be found in S
ECTION 1 of this manual. Do not operate or service the equipment
until you have become familiar with this information.
Section 5: Troubleshooting
To Next Page