Aspen Avionics EFD1000 E5 - Page 11

EFD1000 E5 Dual Electronic Flight Instrument (EFI) Install Manual
DOCUMENT # 900-00041-001 PAGE 11-226 REVISION D
© Copyright 2019 Aspen Avionics Inc.
10.6.6 NAV RECEIVER SENSOR TEST (LABEL AS VLOC1) ......................................................... 164
10.6.7 BACKUP NAVIGATION INDICATOR ............................................................................. 164
10.6.8 AUTOPILOT SENSOR TEST ...................................................................................... 164
10.6.9 ANCILLARY EQUIPMENT HEADING CHECK ................................................................... 165
10.6.10 ANCILLARY EQUIPMENT AIR DATA CHECK .................................................................. 165
10.6.11 INTERNAL BATTERY TESTS ...................................................................................... 165
10.6.12 TAPES CONFIGURATION CHECK .............................................................................. 165
10.6.13 EMI TEST ......................................................................................................... 166
10.6.14 FLIGHT CONTROL INTERFERENCE CHECK .................................................................... 169
10.6.15 OBS MODE CHECK .............................................................................................. 169
10.6.16 EA100 ADAPTER TESTING .................................................................................... 170
11 POST INSTALLATION FLIGHT CHECK ................................................................ 171
11.1 ATTITUDE DISPLAY FLIGHT CHECKS .......................................................................... 171
11.2 HEADING CARD FLIGHT CHECKS .............................................................................. 171
11.3 ILS FLIGHT CHECKS ............................................................................................. 171
11.4 AUTOPILOT FLIGHT CHECKS (IF INSTALLED) ................................................................ 172
11.5 DOCUMENT OPERATIONAL CHECK ........................................................................... 172
12 OPERATING INSTRUCTIONS ............................................................................. 173
12.1 PILOT CONTROLS ................................................................................................ 173
12.1.1 OVERVIEW ......................................................................................................... 173
12.1.2 POWER CONTROL ................................................................................................ 173
13 ENVIRONMENTAL QUALIFICATION FORMS ........................................................ 175
APPENDIX A : TROUBLESHOOTING ...................................................................................... 179
APPENDIX B : INSTALLATION FINAL CHECK SHEET ............................................................... 185
APPENDIX C : SAMPLE OF AFMS SECTION 1.2 (INSTALLED EQUIPMENT CONFIGURATION MATRIX)
190
APPENDIX D : COMPONENT MAINTENANCE MANUAL (CMM) ................................................. 193
APPENDIX E : EA100 ADAPTER ........................................................................................... 195
E1 GENERAL LIMITATIONS ......................................................................................................... 196
E2 EA100 SPECIFICATIONS ......................................................................................................... 197
E3 OUTLINE DRAWING: .............................................................................................................. 198
E4 EA100 SYSTEM ARCHITECTURE ............................................................................................. 198
E5 EA100 INSTALLATION ........................................................................................................... 199
E5.1 EQUIPMENT LOCATION DOCUMENTATION .......................................................................... 199
E5.2 WEIGHT AND BALANCE ...................................................................................................... 199
E5.3 MECHANICAL INSTALLATION .............................................................................................. 199
E5.4 ELECTRICAL INSTALLATION ................................................................................................ 201
E5.5 FABRICATION OF TR1 OR TR2 TRANSFORMER ISOLATION BOX (CENTURY AUTOPILOTS ONLY)203
E5.6 ELECTRICAL CONNECTION ................................................................................................. 204
E5.7 WIRING DIAGRAMS ............................................................................................................. 205
E5.8 CONFIGURATION ............................................................................................................... 220
E5.9 EA100 GROUND TEST PROCEDURE ..................................................................................... 220
E5.9 AUTOPILOT GYRO ALIGNMENT ........................................................................................... 222
E5.10 GROUND EMI TEST ........................................................................................................... 222