PREVOST H3-41 Maintenance Manual

SECTION 00 : GENERAL INFORMATION
PA1621 Maintenance Manual All Series | January 2017
7
4. SAFETY NOTICE
This maintenance manual has been prepared in
order to assist skilled mechanics in the efficient
repair and maintenance of PREVOST vehicles.
This manual covers only the procedures as of
manufacturing date.
Safety features may be impaired if other than
genuine PREVOST parts are installed.
Torque wrench tightening specifications must be
strictly observed. Locking devices must be
installed or replaced by new ones, where
specified. If the efficiency of a locking device is
impaired, it must be replaced.
This manual emphasizes particular information
outlined by the wording and symbols:
DANGER
Directs the operator’s attention to unsafe
practices which could result in serious
personal injury or death.
WARNING
Directs the operator’s attention to unsafe
practices which could result in serious
personal injury or severe damage to the
vehicle.
CAUTION
Directs the operator’s attention to unsafe
practices where personal injury is not likely
but damage to vehicle components could
occur.
NOTE
Indicates supplementary information essential
to the proper operation of the vehicle.
Although, the mere reading of such
information does not eliminate the hazard,
understanding of the information will promote
its correct use.
4.1 DATA PLATES AND CERTIFICATIONS
Delay and confusion can be avoided by placing
the complete vehicle identification number of the
vehicle and the serial numbers of the engine on
parts orders and correspondence. Also, the
transmission, axles, power steering pump
chassis and other major components are
identified by serial numbers.
4.1.1 Engine
FIGURE 1: VOLVO D13 ENGINE DATA PLATE
00052
Volvo D13 engine serial and model numbers are
stamped on the cylinder head. Also, the engine
data plate certifies that the engine conforms to
federal and any state exhaust emission
regulations. It gives the operating conditions
under which certification was made (Figure 1).
4.1.2 Transmission
The transmission identification plate is located
on the oil level dipstick side of the transmission
Allison (World) (Figure 2) or on transmission I-
Shift (Figure 3). The identification plate shows
the transmission serial number, part number
(assembly number), and model number. Use all
three numbers when ordering parts.
FIGURE 2: ALLISON TRANSMISSION 07076

PREVOST H3-41 Specifications

General

Brand	PREVOST
Model	H3-41
Category	Motorhomes
Language	English