4 CLCH-SVX07K-EN
Table of Contents
Factory Training . . . . . . . . . . . . . . . . . . . . . . . 3
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Nameplate . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
General Information . . . . . . . . . . . . . . . . . . . . . 6
Operating Environment . . . . . . . . . . . . . . . . 6
Unit Description . . . . . . . . . . . . . . . . . . . . . . . 6
Pre-Installation . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Receiving and Handling . . . . . . . . . . . . . . . . 8
Jobsite Storage . . . . . . . . . . . . . . . . . . . . . . . 9
Site Preparation . . . . . . . . . . . . . . . . . . . . . . . 9
Dimensions and Weights . . . . . . . . . . . . . . . . 11
Service Clearance Recommendations . . . 11
Section Dimensions and Weights . . . . . . . 13
Fans/Motors . . . . . . . . . . . . . . . . . . . . . . . . . 22
Installation - Mechanical . . . . . . . . . . . . . . . . 23
Lifting and Rigging . . . . . . . . . . . . . . . . . . . 23
Unit Placement and Assembly . . . . . . . . . . 27
Seismic Application Requirements . . . . . . 53
Hurricane Application Requirements . . . . 55
Component Installation . . . . . . . . . . . . . . . . . 61
Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Diffusers . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Fans . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Filters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Multizone Section . . . . . . . . . . . . . . . . . . . . 95
Duct Connections . . . . . . . . . . . . . . . . . . . . . 95
Piping and Connections . . . . . . . . . . . . . . . . 101
General Recommendations . . . . . . . . . . . 101
Drain Pan Trapping . . . . . . . . . . . . . . . . . . 101
Steam Coil Piping . . . . . . . . . . . . . . . . . . . 102
Water Coil Piping . . . . . . . . . . . . . . . . . . . . 104
Refrigerant Coil Piping . . . . . . . . . . . . . . . 105
Liquid Lines . . . . . . . . . . . . . . . . . . . . . . . . . 106
Suction Lines . . . . . . . . . . . . . . . . . . . . . . . 107
Expansion Valves . . . . . . . . . . . . . . . . . . . . 107
Hot Gas Bypass . . . . . . . . . . . . . . . . . . . . . 107
Humidifier Piping and Connections . . . . 108
Remodel, Retrofit, or Replacement . . . . . 108
Field-Installed Evaporator Piping . . . . . . .110
Installation - Electrical . . . . . . . . . . . . . . . . . . .115
Quick Connects . . . . . . . . . . . . . . . . . . . . . .117
CDQ™ Desiccant Wheel Cassette/Motor .117
Typical Wiring Schematics . . . . . . . . . . . . .119
Controls Interface . . . . . . . . . . . . . . . . . . . . . . .125
Connecting the Operator Display . . . . . . .125
Calibrating the Operator Display . . . . . . . .125
External Communications Port . . . . . . . . .126
Start-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .127
Pre-Startup Checklist . . . . . . . . . . . . . . . . . .127
Unit Operation . . . . . . . . . . . . . . . . . . . . . . .128
Airflow Measuring Systems . . . . . . . . . . . .132
Constant Factor K . . . . . . . . . . . . . . . . . . . .138
CDQ Wheel Start Up . . . . . . . . . . . . . . . . . .140
Energy Wheel Startup . . . . . . . . . . . . . . . . .141
External Insulating Requirements . . . . . . .142
Routine Maintenance . . . . . . . . . . . . . . . . . . .143
Maintenance Checklist . . . . . . . . . . . . . . . .143
Air-to-Air Plate Heat Exchangers . . . . . . . .144
Cleaning the Unit . . . . . . . . . . . . . . . . . . . . .144
Coils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .145
Drain Pans . . . . . . . . . . . . . . . . . . . . . . . . . . .147
CDQ Desiccant Dehumidification Wheel .147
Energy Wheels . . . . . . . . . . . . . . . . . . . . . . .154
Fans . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .160
Filters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .162
Moisture Eliminator . . . . . . . . . . . . . . . . . . .162
Ultraviolet (UV) Light Maintenance . . . . .162
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . .165