ABB SCK - Page 71

OI/SCK
-EN Rev. E Operating instruction SCK Gas Sampling System 71
Danger Where / in what situa-
tion does the danger
arise?
Preventive action
Danger due to
harmful gases
Due to gases escaping
from the duct opening
of the rotary kiln
 Only enter the danger
area around the retractor
when the shutter is
closed.
 Lock the shutter before
commencing work.
 Ensure adequate ventila-
tion of the work place.
 If work is unavoidable in
the area of the duct open-
ing, wear respiratory pro-
tection in addition to the
general protective
equipment.
Danger due to
harmful anti-freeze
In the cooling water of
the cooling system

Avoid contact with the
cooling water and the an-
ti-freeze.
 Wash any cooling water
or anti-freeze off the skin
immediately with water
and soap.
 If cooling water or anti-
freeze gets in the eyes
despite protective glass-
es, rinse them thoroughly
under running water,
holding the eyelids open.
 Observe instructions in
the anti-freeze manufac-
turer's safety data sheet.
Danger due to
harmful lubricating
oil
In the pneumatic box,
on the pneumatic
motor filter muffler,
inside the pneumatic
motor.

Avoid contact with lubri-
cating oil.
 Wash any lubricating oil
off the skin immediately
with water and soap.
 If any lubricating oil gets
in the eyes despite pro-
tective glasses, rinse
them thoroughly under
running water, holding
the eyelids open.
 Observe instructions in
the lubricating oil manu-
facturer's safety data
sheet.