ActronAir ELY620T

To Previous Page

ActronAir is constantly seeking ways to improve the design of its products, therefore speciﬁcations are subject to change without notice.

Document: 0525-098 Issue Date: 03/2021

Refrigerant Trading Authorisation

No.: AU06394

Main Page

Table of Contents2
Introduction4
Product Inspections4
Codes, Regulations and Standards4
General Information4
Safety Precaution6
Installation Information7
Unit Mounting and Location8
Components Overview9
Outdoor Unit9
Indoor Unit - Standard Profile10
Indoor Unit - Low Profile11
Outdoor Dimensions12
CAY500T Unit Dimension12
CAY620T - CAY700T Unit Dimension13
Outdoor Base Dimension14
Indoor Dimensions15
EVY500T Unit Dimension15
EVY620T - EVY700T Unit Dimension16
ELY500T Unit Dimension17
ELY620T - ELY700T Unit Dimension18
Unit Lifting Procedure19
Crane Lifting Method19
Fork Lift Method20
Condensate and Safety Tray Drainage Instructions21
Banking of Outdoor Units22
End-To-End Configuration22
Cluster Configuration22
Side-By-Side Configuration22
Layout - Outdoor Unit Control Box23
Standard Model23
Standard Model with Optional 3-Phase Protection Relay23
Standard Model with Optional 3-Phase Soft Starters24
With Optional EC Outdoor Fans25
With Optional EC Outdoor Fans and 3-Phase Protection Relay25
With Optional EC Outdoor Fans and 3-Phase Soft Starters26
Indoor Unit Control Box - Standard Models27
Unit Preparation28
Outdoor Unit - Interconnecting Pipes Installation28
Compressor Shipping Blocks Removal29
Electrical Mains30
Piping31
Piping Connection31
Example Total Equivalent Field Pipe Length Calculations32
Pipe Installation33
Electrical36
Split Unit Electrical Connection36
Maximum Cable Lengths37
BMS Control Wiring Procedures38
Return Air - Outside Air - Spill Air Control Wiring Procedures39
Demand Response Management40
Control Menu41
Menu Navigation41
Service Password41
Menu Tree42
Main / Status Menu42
Service Menu43
Manufacturer Menu45
External Input Operation46
Unit ON/OFF Configuration46
EC Indoor Fan Commissioning46
Compressor Configuration52
Internal Sensor Operation55
Unit ON/OFF Configuration55
Indoor Fan Configuration57
Setting up Bms (Remote Demand) Optional59
Setting Economy Cycle Operation59
Setting Economy Cycle Type59
Room Air Temperature Sensor Installation61
Room Air Temperature Sensor Wired to Indoor Unit61
Room Air Temperature Sensor Wired to Outdoor Unit61
Room Air Temperature Setup in Control Interface62
Indoor / Outdoor Setup62
Averaging Four Room Air Temperature Sensors (Optional)63
Room Temperature Sensor Adjustment Instructions63
Specifications - Sensor Lead Wire63
After Hours Logic with Timeclock (Scheduler)64
After Hours Wiring to Outdoor Unit64
Operational Logic64
Enable / Disable Air Filter Alarm65
External Input Wiring Diagrams66
24VAC Relay Output Compressors and Indoor Fans66
Analogue Output Compressor and 24VAC Relay Output Indoor Fans67
24VAC Relay Output Compressor and 0-10 Analogue Output Indoor Fans68
Wiring Diagram 0-10 Analogue Output Compressors and Indoor Fans69
Fan Performance Data and Curve70
Refrigerant Charging76
Charging Method 1: Subcooling and Superheat77
Charging Method 2: Cooling Charging Curve80
Thermal Expansion Valve (TXV) Adjustment81
Fault Display Codes82
Control Fault Code Displays82
Soft Starter Display Codes83
Indoor Board Fault Code Displays83
Maintenance84
Maintenance Frequency Checklist86
Sensor Detail88
Start-Up and Commissioning Report89
Installation and Commissioning Guide 500-700 Tri-Capacity Split Ducted91

ActronAir ELY620T - Page 92

Table of Contents

Related product manuals