Home
Case
Excavators
570T
Case 570T User Manual
4
of 1
of 1 rating
246 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
7
-
MAINTENANCE
13.
Fill
1
1
l
(
3
US
gal
)
engine
oil.
14.
Start
the
engine
and
let
it
run
for
several
minutes
and
then
check
the
level
again
by
means
of
the
dipstick.
15.
If
necessary
,
top
up
to
compensate
the
quantity
of
oil
used
for
lling
the
cartridge.
16.
Lower
and
lock
the
engine
tilt
hood.
17.
Remove
the
safety
support
strut
and
lower
the
loader
attachment.
PTIL12TLB0226A
2
7-40
161
163
Table of Contents
Foreword
9
Note to the Owner
10
Intended Use
11
Electro-Magnetic Compatibility (EMC)
13
Product Identification
14
Component Identification
18
Safety Rules
19
Ecology and the Environment
26
Hand Signals
27
Backhoe Buckets
32
Safety Signs
34
Access to Operator's Platform
43
Operator's Seat
46
Front Controls
47
Pedal Controls
49
Transmission Controls
51
Right Hand Side Controls
54
Instrument Cluster - Front
56
Instrument Cluster Panel – Side
57
Instrument Cluster
58
Heating, Ventilation, Air Conditioning (HVAC) Controls
60
Cab and Platform - Control Identification
61
Loader Attachment Controls
63
Loader Attachment – Operation
64
Booms, Dippers, and Buckets - Control Identification
69
Left-Hand Stabilizer Left-Hand Control Lever
72
Right-Hand Stabilizer Right-Hand Control Lever
73
Slider Frame Control Pedal
74
Commissioning the Machine
75
Operating the Machine
76
Road Operation
77
Job Site Operation
78
Starting the Engine
79
Assisted Starting (Jump-Starting)
80
Starting the Engine - at Low Temperatures
81
Stopping the Engine
82
Moving the Unit
83
Parking the Unit
86
Requirements for Road Travel
87
Precautions for Road Travel
88
Preparing the Machine for Road Travel
89
Setting the Backhoe Attachment in Road Travel Position
92
Locking or Unlocking the Backhoe Attachment
94
Machine Transport (on a Trailer)
95
Towing the Machine
96
Operating the Machine in Cold Weather
99
Operating the Machine in High Altitude
100
Operating the Machine in High Temperatures
101
Operating the Machine in Water
102
Lifting the Machine
103
Organizing the Job Site
104
Transmission Disconnect Button
105
Operating the Loader Attachment
106
Loader Attachment Safety Strut
109
Loader Bucket – Removal
110
Loader Bucket – Install
111
Backhoe Attachment
112
Setting the Backhoe Attachment in Working Position
113
Operating the Backhoe Attachment
114
Filling the Backhoe Bucket
115
Moving the Machine Forwards When Working
116
Trenching
117
Backhoe Bucket Remove
119
Backhoe Bucket Install
120
Backhoe Bucket – Digging Angle
121
Fluids and Lubricants
123
Fuel
124
Fuel Storage
125
Fuel Tank
126
Hydraulic Oil
127
Hydraulic Oil Tank
128
Engine Oil Viscosity
129
Safety Instructions
130
Machine Safety
131
Work Hours and Intervals
132
Maintenance Chart
133
Parking Brake
134
Fuses and Lamps
135
Functionality of Controls and Lamps
137
Drive Belts - Check
138
Engine Oil Level - Check
139
Transmission Oil Level - Check
140
Engine Coolant Level - Check
141
Hydraulic Oil Level - Check
142
Fuel Tank Level - Check – Level
143
Restriction Indicator– Check
144
Grease Points – Lubricate
145
Engine Oil and Oil Filter – Change
147
Fan / Alternator Belt Tension
149
Battery Electrolyte Level - Check
150
Wheels Re-Torque
151
Hydraulic System Breather - Clean
152
Battery Check
153
Front Axle Breather (4WD Only) - Clean
154
Water Separator Drain
155
Rear Axle Differential Oil - Check
156
Engine and Cabin Mounting Bolts Re-Torque
157
Front Axle Hub Oil Level (4WD Only) – Check
158
Stabilizer Wear Pads Adjust
159
Engine Oil and Oil Filter – Change
161
Mud Filter - Change
163
Fuel Filter - Change
164
Powershuttle Transmission – Oil Change
165
Transmission Oil Filter - Replace
166
Transmission Suction Strainer - Cleaning
167
Hydraulic Oil Filter - Replace
168
Front Axle Hub Oil (4WD Only) - Replace
169
Rear Axle Hub Oil - Replace
170
Front Axle Differential Oil (4WD Only) - Replace
171
Rear Axle Differential Oil - Replace
172
Front Axle - Hub Greasing 2WD
173
Check the Fuel Injector
175
Hydraulic Oil - Replace
176
Engine Coolant - Replace
177
Radiator and Oil Cooler Fin - Cleaning
179
Engine Air Filter
180
Tires Pressure - Check
182
Radiator - Cleaning
184
Condenser - Cleaning
185
Pollen Filter - Cleaning
186
Storing the Machine
187
Short Term Storage
188
Storing the Engine
189
Battery Storage
190
Taking the Machine Back to Service
191
Removal from Storage
192
Engine - Troubleshooting
193
Starter Motor - Troubleshooting
195
Alternator - Troubleshooting
196
Transmission - Troubleshooting
197
Axles - Troubleshooting
199
Steering System - Troubleshooting
202
Hydraulic Systems - Troubleshooting
203
Loader Attachment - Troubleshooting
204
Backhoe Attachment - Troubleshooting
205
Swing - Troubleshooting
206
Hydraulic Pump - Troubleshooting
207
Electrical Systems - Troubleshooting
208
Heating, Ventilation, Air Conditioning (HVAC) - Troubleshooting
209
Specifications
211
Material Weights – Material
220
Torque Chart – Metric Non-Flanged Hardware
221
Torque Chart – Metric Flanged Hardware
222
Identification
223
Torque Chart – Inch Non-Flanged Hardware
224
Torque Chart – Inch Flanged Hardware
225
Identification
226
Units of Measure and Conversion
227
Other manuals for Case 570T
Service Manual
22 pages
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Case 570T and is the answer not in the manual?
Ask a question
Case 570T Specifications
General
Brand
Case
Model
570T
Category
Excavators
Language
English
Related product manuals
Case 580M
31 pages
Case 580C
74 pages
Case 580SR
31 pages
Case 590SR
31 pages
Case 580 ck
74 pages
Case 580SR+
1068 pages
Case 580 SUPER M
31 pages
Case 590 SUPER M
31 pages
Case 120
38 pages
Case CX145C SR
306 pages
Case CX Series
273 pages
Case CX220C 2 Series
22 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
