Helmer iBX080 - Page 73

To Previous Page

HELMER SCIENTIFIC

14400 Bergen Boulevard

Noblesville, IN 46060 USA

PH +1.317.773.9073

FAX +1.317.773.9082

www.helmerinc.com

Main Page

Notes and Disclaimers2
Table of Contents3
Section I: General Information6
About this Manual6
Intended Audience6
Model References6
Copyright and Trademark6
Safety6
Safety Definitions6
Product Labels7
Avoiding Injury7
Compliance8
Regulatory Compliance8
WEEE Compliance8
Electromagnetic Compliance8
Manufacturer8
Model and Input Power8
Section II: Installation & Configuration10
Location Requirements10
Install Components10
Packing List10
Place Compartmental Access Refrigerator10
Configure the Access Console10
Attach the Access Console to the Compartmental Access Refrigerator11
Place the Consumable Cart13
Attach the Access Console to a Wall15
Attach the Access Console to a Table15
Connect External Monitoring Devices15
Connect AC Power Cord and Ethernet Cable for Access Console16
Connect AC Power Cord for Compartmental Access Refrigerator18
Connect Backup Power18
Power-Up I.C 3 Backup Battery18
Power-Up Access Console Backup Battery19
Prepare for Monitoring19
Temperature Probes19
Air Probe20
Upper Chamber Probe20
Condenser Probe20
Install Additional Probe through Top Port20
Chart Recorder (Optional)20
Chart Recorder Access21
Install Chart Paper21
Reorder Chart Paper21
Control System22
Home Screen and Haemobank™ Screensaver22
Home Screen Functions22
Alarm Reference22
Settings23
Temperature Settings23
Sensor Calibration24
View Sensor Calibration Values24
Change Sensor Calibration Offset Values25
Factory Default Settings25
Restore Factory Default Settings26
View System Information26
Section III: Maintenance & Service27
Alarm Tests27
Automatic Chamber Temperature Alarm Test27
Manual Chamber Alarm Test28
Power Failure Alarm Test29
Door Open Alarm Test29
Upgrade System Firmware29
Test and Replace Backup Batteries29
Test the I.C 3 ® Monitoring System / Access Control Backup Battery29
Replace the I.C 3 ® Monitoring System / Access Control Backup Battery30
Check the Access Console Backup Battery30
Replace the Access Console Backup Battery30
Check the Chart Recorder Backup Battery (if Installed)31
Replace the Chart Recorder Backup Battery32
Check Probe Bottle32
Check Probe Bottle Solution32
Inspect and Replace Probe Bottle32
Inspect and Secure Electrical Wiring and Terminals33
Clean the Compartmental Access Refrigerator and Access Console34
Compartmental Access Refrigerator Condenser Grill34
Compartmental Access Refrigerator Exterior34
Access Console and Consumable Cart Exterior34
Compartmental Access Refrigerator Interior34
Door Gaskets35
Clean the Tray Assembly35
Clean Probe Bottle and Refill Solution35
I.C³ Touchscreen36
Bloodtrack Kiosk36
Bypass System Check and Reset36
Service37
Refrigerant Charge37
Replace Chamber LED Lamp Strip37
Maintaining Tray Assembly38
Remove and Install a Tray and Cover38
Replace Tray Bumpers40
Section IV: Troubleshooting41
Troubleshooting41
Compartment Access Circuit Boards and Sensors Diagnostic References41
IRACS Horizontal Circuit Board LED Indicators41
Check Circuit Board Status41
Check Proximity Sensor Status42
Check Solenoid Status42
Check Voltage Conversion Status43
IRACS Addresses43
Initiate Diagnostic Mode44
Network Communications Reference Guide45
Bloodtrack ® Interfaces45
General Operation Problems46
Chamber Temperature Problems47
Alarm Activation Problems50
Testing Problems52
Condensation Problems52
Access Control Lock Problems53
Compartment Assembly Problems54
Access Console Problems55
Section V: Parts & Schematics56
Parts56
Front57
Control System and Display58
Refrigeration Components59
Electrical Box Components60
Compartment Access Components61
Access Console Components62
Rear63
Interior64
Unit Cooler64
Rear66
Door and Hinge67
Spare Parts68
Schematics69
Compartmental Access Refrigerator Schematic69
Access Console Schematic72

Helmer iBX080 - Page 73

Table of Contents

Related product manuals