Sharp MX-2300 G

MX-2300/2700 N/G MAINTENANCE 9 – 2
Transfer
section
Secondary belt
follower roller
Mechanical
parts
✕✕{ ✕✕{ ✕✕{ ✕✕{
Secondary transfer
idle gear
✕✕✕▲✕✕▲✕✕▲✕✕▲(P/G No.: [29]-6)
Sensors (Process
control resist
sensors)
✕ {{{{{{{{{ { { {
Primary CL roller ▲▲▲▲▲▲▲▲▲ ▲ ▲ ▲(P/G No.: [26]-56)
Cleaner seal ✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕
Cleaner seal R ✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕
Transfer toner
reception seal
✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕
Fusing
section
Upper heat roller Mechanical
parts
✕ ✕▲✕▲✕▲✕▲✕ ▲ ✕ ▲(P/G No.: [32]-32)
Lower heat roller ✕ ✕▲✕▲✕▲✕▲✕ ▲ ✕ ▲(P/G No.: [33]-15)
Upper heat roller
gear
✕ ✕▲✕▲✕▲✕▲✕ ▲ ✕ ▲(P/G No.: [32]-30)
Upper roller bearing ✕ ✕▲✕▲✕▲✕▲✕ ▲ ✕ ▲(P/G No.: [32]-31)
Lower roller bearing ✕ ✕▲✕▲✕▲✕▲✕ ▲ ✕ ▲(P/G No.: [33]-14)
Upper separation
pawl
✕ ✕▲✕▲✕▲✕▲✕ ▲ ✕ ▲(P/G No.: [32]-11)
Upper thermistor ✕ ✕▲✕▲✕▲✕▲✕ ▲ ✕ ▲(P/G No.: [32]-18)
Lower thermistor ✕ ✕▲✕▲✕▲✕▲✕ ▲ ✕ ▲(P/G No.: [33]-20)
Non-contact
thermistor
✕✕✕▲✕✕▲✕✕▲✕✕▲
Gears ✕ ✩✩✩✩✩✩✩✩✩ ✩ ✩ ✩Specified position
Paper guides { {{{{{{{{{ { { {
Fusing unit ✕ ✕▲✕▲✕▲✕▲✕ ▲ ✕ ▲(P/G No.: [31]-901)
(P/G No.: [32]-901)
(P/G No.: [33]-901)
Filters Ozone filter PA Mechanical
parts
✕ ▲▲▲▲▲▲▲▲▲ ▲ ▲ ▲(P/G No.: [47]-40)
Paper feed
section
Pickup roller Mechanical
parts
{ {{{{{{{{{ { { {(P/G No.: [11]-40,
[16]-33)
Paper feed roller { {{{{{{{{{ { { {(P/G No.: [11]-41,
[16]-29)
Separation roller { {{{{{{{{{ { { {(P/G No.: [10]-4,
[15]-37)
Torque limiter ✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕
Transport
section/
Paper exit
reverse
section
PS follower roller Mechanical
parts
✕ {{{{{{{{{ { { {
Transport rollers { {{{{{{{{{ { { {
Discharge brush ✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕
Paper exit filter
Gears ✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕When checking, apply
to the necessary
positions (specified
positions).
Drive
section
Gears (Grease) Mechanical
parts
✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕HANARL FL955R/
FLOIL G313S
When checking, apply
to the necessary
positions (specified
positions).
Shaft earth sections
(Conduction grease)
✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕When checking, apply
to the necessary
positions (specified
positions).
Belts ✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕
Others Sensors Mechanical
parts
✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕
Image quality Mechanical
parts
✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕
Optical
section
Mirror/Lens/
Reflector/CCD
Mechanical
parts
{ {{{{{{{{{ { { {
Table glass/
SPF glass
{ {{{{{{{{{ { { {
Scanner lamp { {{{{{{{{{ { { {
Rails ✩ ✩✩✩✩✩✩✩✩✩ ✩ ✩ ✩Specified positions
Drive belt/
Drive wire
✕ ✕✕✕✕✕✕✕✕✕ ✕ ✕ ✕
Unit name Part name
Monochrome
supply/
Mechanical
parts
When
calling
100
K
200
K
300
K
400
K
500
K
600
K
700
K
800
K
900
K
1000
K
1100
K
1200
K
Remark/Refer to the
Parts Guide.
Block/Item No.
(Only the replacement
parts are described.)
1
: Dec. 15 2005
1