SUNWARD SWE18UF - Protection for Long-Term Storage

OPERATION & MAINTENANCE MANUAL SWE18UF
105
On dusty or hot condition
1． More frequently clean the air filter element.
2． Wash the radiator and oil cooler cooling fin to remove dust and
dirt.
3． More frequently clean the fuel sucking filter and its core.
4． Termly carry out clean maintenance, especially the surface of
the engine and generator.
On the stony ground
1. Carefully operate the machine. Check if the undercarriage and
track assembly are over damaged or worn.
2. Check for the loosen、damaged and lost connector、bolts and nuts.
3. More frequently check the over damaged and worn bucket and
breaker.
4. Install a top frame and front frame if necessary to prevent damage
caused by fallen subjects.
In cold weather
1. Use high quality, low glutinosity oil, which fit the environment
temperature.
2. Make sure to use the antifreeze, which fit the temperature.
3. Charge the battery a little bit before the usual time. If the battery is
not completely charged, the electrolyte may be frozen.
4. Clean all the dirt on machine to prevent possible damage caused
by frozen dirt.
5.2.10 Protection for Long-Term Storage
If the excavator should be stored for over 1 month, the following protection should be adopted to maintain its
function during the store period.
Protection for long term store
Maintenance
Details
Clean machine
Completely clean the machine, fix any malfunction.
Add lubricant oil and grease
Check the lubricant to find if it is dirty or insufficient. Add lubricant to
the parts, which need this. And apply a layer of oil.
Battery
Take off the battery and charge it then restore it.
Coolant
Add antirust. Add Ethylene glycol if it is possible to be frozen; or vent
out all the coolant, and hang a label：“No water in radiator” in the cab.