Textron EZGO RXV 2016 User Manual

FAULT TESTING
Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
137
System not adjusted properly Check and adjust per manual
End of brake cable loose from anchor
brackets
Check and repair
IN EXCESS OF 1" (2.5 CM) FREE
PEDAL TRAVEL (SOFT PEDAL)
Cracked brake drum Replace
Low pedal force at parking brake latch Adjust per manual
Brake cables damaged Replace
Brake return bumper out of adjustment Adjust per manual
End of brake cable loose from anchor
brackets
Check and repair
Wheel brake failure due to severely
worn or damaged components
Replace all severely worn or damaged
components
LESS THAN 3/4” (1.9 CM) FREE
PEDAL TRAVEL (HARD PEDAL)
System not adjusted properly Adjust per manual
High pedal force at parking brake latch Adjust per manual
Brake cables damaged or sticky Check brake cable and replace if sticky or
damaged
System not adjusted properly Check and adjust per manual
Wheel brake failure due to severely
worn or damaged components
Replace all severely worn or damaged
components
NEITHER WHEEL LOCKS WHEN
PARK BRAKE IS LATCHED. (NOTE:
AT FULL SPEED THE WHEELS MAY
NOT LOCK, BUT SHOULD BRAKE
AGGRESSIVELY).
Incorrect cable adjustment Return to factory specification
Excessive brake pedal free travel Adjust per manual
UNEQUAL BRAKING (ONE WHEEL
LOCKS WHILE OTHER ROTATES)
Wheel not locking/not adjusting Check brake operation of wheel that is not
locking
Adjust per manual
Sticky/dragging cable Check for brake lever return
Adjust such that brake levers return at
equal rate - (Indication of dragging cable)
Cracked brake drum Replace
Brake shoes wet or glazed Check and make sure shoes are dry
NEITHER WHEEL LOCKS
Rusted or sticky brake pivot hardware Replace
Brake system requires complete
adjustment
Adjust entire system
Brake pedal not returning Check for binding of brake pedal, if neces-
sary adjust/replace the brake pedal
Check/adjust brake pedal free travel
GRABBING BRAKES
(OVERSENSITIVE)
Moisture has caused surface rust on
drums
Apply moderate force to pedal while at
maximum level ground speed to remove
rust until condition is relieved.
Brake pivot binding Check and replace poor components
Condition Possible Cause Correction

Textron EZGO RXV 2016 Specifications

General

Brand	Textron
Model	EZGO RXV 2016
Category	Golf Cars
Language	English