Claas DOMINATOR 130 - Page 270

270 00 0293 210 2 - BA DOMINATOR 150/140/130 - 12/09
13 Maintenance
13.3 Maintenance schedule
67089
Diesel engine air filter change ••
Diesel engine air filter safety
cartridge
change (or after servicing the
main filter cartridge five
times)
• •
air filter intake sieve clean ••
Air intake pipes change •
Clamps on air suction hoses retighten •
Chassis
Wheel nuts of drive axle tyres, tight-
ening torque
check
•** •*
*immediately after installation.
*after the first working hour
**during the first 50 working
hours: every 10 working hours
Wheel nuts / wheel bolts of rear axle
tyres tightening torque
check
• • •*
*immediately after installation.
Gearbox drive axle surroundings clean ••
Final drives Oil level check • •
Final drives Oil change ••
Rear axle gearbox Oil level check • •
Rear axle gearbox Oil change ••
Adjusting the chassis clutch
DOMINATOR 130
adjust
•
Adjusting the short-circuit valve
DOMINATOR 130
adjust
•
Brake
Brake fluid level check •• •
Brake fluid change (only through authorised
workshop)
•
Parking brake adjust (only through authorised
workshop)
•
Foot brake adjust (only through authorised
workshop)
•
Brake pads check •• •
Output / drives
Belts (all) adjust •••
Chains (all) adjust • • •
Maintenance operations Service intervals in working hours
Before the harvest
After the
first
Daily
Every
Once a year or every 500 every 2 years As required After the harvest
10 100 50 100 250