Intel M50CYP1UR Series

To Next Page

To Previous Page

Intel® Server System M50CYP1UR Family System Integration and Service Guide

Document Revision History

Date

Revision

Changes

May 2021

1.0

Initial production release

Main Page

Safety Warnings5
Electrostatic Discharge (ESD)5
Weight of the System6
Table of Contents7
List of Figures10
Introduction14
System Integration15
System Service15
L6 Integrated System - Essential System Component Installation18
Before You Begin18
Instruction Format18
Chassis Component Identification19
System Cover Removal / Installation19
System Cover Removal19
System Top Cover Panel Shipping Screws20
System Cover Installation21
Processor Assembly and Installation21
Components Required21
Required Tools and Supplies21
U Heat Sinks22
Processor Heat Sink Module (PHM) Reference Diagram22
Processor Heat Sink Module (PHM) Assembly23
Installing Processor Carrier Clip Onto Processor23
Removing Heat Sink from Its Packaging24
Setting the Processor Heat Sink Anti-Tilt Wires to Outward Position25
Pin 1 Indicator of Processor Carrier Clip25
Processor Installation26
PHM Alignment with Socket Assembly26
PHM Installation Onto Server Board27
Tighten Heat Sink Extension Fasteners27
Memory Module Installation28
DIMM Installation28
DIMM Blank Removal28
Power Supply Module Installation30
System Options / Accessory Kit Installation31
Riser Card Bracket Removal36
Riser Card Installation36
Riser Card Installation Onto the Bracket36
Pcie* Add-In Card Installation37
Pcie* Add-In Card Installation for Riser Card on Riser Slot38
2.5” Drive Bay Components40
2.5” SSD Drive Assembly for 7 MM Drives40
Separating Top and Bottom Parts of Drive Blank40
2.5” SSD Drive Installation41
2.5” 7 MM Drive Outside Chassis, Ready for Installation41
2.5” SSD Drive / Drive Blank Removal43
Ethernet Network Adapter for OCP* – Installation / Removal44
OCP* Adapter Bay Filler Removal / Installation45
To Remove the Filler45
To Install the Filler45
OCP* Adapter with Pull Tab Installation46
OCP* Adapter with Pull Tab Removal46
OCP* Adapter with Ejector Latch Installation47
OCP* Adapter with Internal Lock Installation47
Internal Lock with Unlock and Lock Orientation48
OCP* Adapter with Internal Lock Removal49
M.2 Storage Device Installation / Removal49
M.2 SSD Installation50
M.2 SSD Removal50
Trusted Platform Module (TPM) Installation51
Intel VROC 7.5 Key Installation / Removal51
Intel SAS Interposer Card Installation54
SAS Interposer Card Installation54
Intel SAS Interposer Card Removal55
Intel SAS RAID Module Installation56
Intel SAS RAID Module Removal57
Installing Latch on the Plastic Case58
Insert Super Cap58
Intel RMFBU Mounting Bracket Installation59
Intel RMFBU Mounting Bracket Removal59
System Software Updates and Configuration60
System Service – System Features Overview61
Front Drive Bay Options61
Back Panel, Front Control Panel, Front I/O Features61
Front Control Panel Features62
Front I/O Features62
Drive Bay LED Identification63
Hot Swap Drive Bay LED Identification63
Drive Status LED States63
Drive Activity LED States63
Server Board Features64
System Configuration and Recovery Jumpers66
Reset and Recovery Jumper Block Locations66
System Service and FRU Replacement67
Memory Module Replacement71
Power Supply Replacement73
Processor Replacement74
Processor Heat Sink Module (PHM) and Processor Removal74
PHM Assembly Removal from Processor Socket74
Reinstall the Socket Cover75
Processor Removal from PHM Assembly75
Processor Carrier Clip Removal from PHM Assembly76
X 2.5” Backplane Removal86
4 X 2.5” Backplane and 12 X 2.5” Backplane Cabling89
System Cable Routing Channels90
System Battery Replacement91
Replacing the System Battery91
Server Board Replacement92
Server Board Installation93
Getting Help94
Internal Cable Routing Channels95
General Memory Population Rules96
DDR4 DIMM Population Rules96
System Status LED Operating States and Definition99
POST Code Diagnostic LED Decoder101
Early POST Memory Initialization MRC Diagnostic Codes102
POST Progress Code LED Example102
MRC Progress Codes102
MRC Fatal Error Codes103
BIOS POST Progress Codes104
POST Code Errors107
POST Error Messages and Handling108
POST Error Beep Codes113
Integrated BMC Beep Codes113
Processor Initialization Error Summary114
Mixed Processor Configurations Error Summary114
System Packaging Assembly Instructions116
Safety Instructions119

Intel M50CYP1UR Series

Table of Contents

Related product manuals