5 Maintenance
Inspection and maintenance overview
Service plan as required
Carried
out
9
8
Engine
Clean the fuel tank ventilation hose
Drain water from the fuel filter
Change the air filter cartridge (after no longer than 1000 operating hours)
Change the safety cartridge in the air filter (after no longer than 3000 operating
hours)
Check the dust discharge valve
Change the oil bath air filter oil
Clean the prefilter
Clean the water cooler and hydraulic oil cooler, and check them for leaks
Regenerate the particulate filter
Drain water from the water trap at the exchangeable particulate filter
Chassis, bodywork and fittings
Clean the truck
Service the air conditioning
Check condition and correct operation of the seat belt
Chassis frame
Wheel change
Clean and grease the steering axle (after no longer than 1000 operating hours)
Check tyres for damage and foreign bodies
Tighten wheel fastenings (after each maintenance or repair, no longer thanevery
100 operating hours)
Hydraulics
Check function and safety system of third auxiliary hydraulics
Load lift system
Clean the lift mast chain, adjust and apply chain spray
Special equipment
Washer system: Top up the water tank
102 Operating Instructions – 393 807 1001 EN – 08/2008
To Next Page
Loading...
