Linde H35D - Exchanging the Fuel Filter; Cleaning the Fuel Tank Ventilation Hose

Maintenance 5
Engine
Exchanging the fuel filter
(at the latest after 12 months)
ENVIRONMENT NOTE
Observe information about work
ing with con-
sumables.
d3921495
1
¾ Unscrew 3 screws from the maintenance
cover (1) on the right side of the forklift truck.
¾ Remove the maintenance cover.
d3921494
2
3
4
¾ Place a collection v
essel under the fuel filter
(2).
¾ Clean the outside of the fuel filter.
¾ Unscrew the old filter and dispose of it in an
environmentally friendly manner.
¾ Clean the sealing fac
e of the filter top (4).
¾ Lightly wet a new sealing ring (3) with fuel.
¾ Tighten the new filter (2) until the sealing
ring (3) lies against the filter top (4).
¾ Fully tighten the filte
r by hand.
¾ Start the engine and check for leaks.
If necessary, tighten the filter further by hand.
¾ Refit the maintenance co
ver.
Cleaning the fuel tank ventilation
hose
When operating the truck in dusty and dirty
conditions, the ventilation hose (1) to the fuel
tank can become blocked. It must therefore
Operating Instructions – 393 807 1001 EN – 08/2008 121