Maeda CC1485S-1 - Engine Components

220
8.4.3 ENGINE COMPONENTS
• Make sure that you contact us or our sales service agency for the actions marked with
in the table.
• Ask us or our sales service agency for repair if you suspect any other abnormalities or
causes than those given below.
Abnormal Phenomenon
Major cause(s)
Remedy
Engine oil pressure error is
displayed while the engine is in
operation.
• Lack of oil in oil pan (air
suction)
• Oil filter cartridge clogged
• Defective fastening of oil
pipe and joints, oil leaks
due to breakage
• Defective engine oil
pressure sensor
• Defective monitor
• See “Check before
operation” and adjust oil
level to appropriate one.
• See “Periodical
Maintenance” to check, or
replace.
Inspection and repair
Replacement
Replacement
Steam spouts out from the upper
part (pressure valve) of radiator.
• Lack of coolant
• Water leakage from the
cooling line
• Looseness of fan belt
• Accumulation of dust and
fur in cooling system
• Radiator fin clogged
• Defective thermostat
• Looseness of radiator cap
(during work at elevation)
• Defective monitor
• See “Check before
operation” and refill coolant.
Inspection and repair
• See “Periodical
Maintenance” to adjust, or
change the belt.
• See "Irregular
Maintenance" to change
coolant and clean inside of
cooling system.
• See “Periodical
Maintenance” to check,
clean or repair.
Replacement
• Tighten cap or replace
packing.
Replacement
Engine coolant temperature error
is displayed.