Table of Contentsii
Publication 1336 IMPACT-6.8 – November, 2002
Chapter 2
Chapter Objectives 2–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fault/Warning Handling 2–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Viewing the Fault and Warning Queues on the HIM 2–2. . . . . . . . . . . .
Fault Descriptions 2–3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Procedures by Symptom 2–16. . . . . . . . . . . . . . . . . . . . . . .
Drive Will Not Start or Jog 2–16. . . . . . . . . . . . . . . . . . . . . . . . . . . .
No HIM Display 2–17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HIM Displays “Running” 2–18. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Motor Response Not As Desired 2–19. . . . . . . . . . . . . . . . . . . . . . . .
Start Up Troubleshooting Procedures 2–20. . . . . . . . . . . . . . . . . . . . . .
Miscellaneous Troubleshooting Procedures 2–20. . . . . . . . . . . . . . . . . .
Encoderless Troubleshooting Procedures 2–22. . . . . . . . . . . . . . . . . . .
Chapter 3
Chapter Objectives 3–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Access Overview 3–1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrostatic Discharge Precautions 3–2. . . . . . . . . . . . . . . . . . . . . . .
Tools 3–2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastener Torque Specifications 3–3. . . . . . . . . . . . . . . . . . . . . . . . . . .
Torque Sequence 3–3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Torque Specifications 3–4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Access Procedures 3–6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Opening the Drive Enclosure 3–6. . . . . . . . . . . . . . . . . . . . . . . . . .
Opening 3–7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Closing the Drive Enclosure 3–9. . . . . . . . . . . . . . . . . . . . . . . . .
Removing the Control Board Mounting Plate 3–10. . . . . . . . . . . . . . .
Removal 3–10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 3–11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Removing the Precharge Board Mounting Frame 3–12. . . . . . . . . . . .
Removal 3–12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 3–13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Removing the Motor Buses 3–14. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 3–14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 3–16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pulling the Capacitor Bank Assembly 3–17. . . . . . . . . . . . . . . . . . . .
Removal 3–17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 3–22. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pulling the Inverter Assembly 3–23. . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 3–23. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 3–27. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Removing Diode and SCR Heat Sinks 3–28. . . . . . . . . . . . . . . . . . . .
Removal 3–28. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 3–30. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Troubleshooting and Error
Codes
Access Procedures