Capstone Microturbine C1000 Series User Manual

Capstone Turbine Corporation • 16640 Stagg Street • Van Nuys • CA 91406 • USA
Installation Guide: Capstone C1000S/C800S/C600S with C1000 Series Controller
480064 Rev C (December 2018) Page 7 of 122
Capstone reserves the right to change or modify, without notice, the design, specifications, and/or contents of this document without
incurring any obligation either with respect to equipment previously sold or in the process of construction.
Figure 42. Stand Alone Load Configuration ............................................................................... 92
Figure 43. Delta/Delta Isolation Transformer ............................................................................. 93
Figure 44. Delta/Wye Isolation Transformer .............................................................................. 94
Figure 45. Wye/Delta Isolation Transformer .............................................................................. 95
Figure 46. Wye/Wye Isolation Transformer ............................................................................... 96
Figure 47. One to Three Microturbines ...................................................................................... 97
Figure 48. Four Microturbines ................................................................................................... 98
Figure 49. Five Microturbines .................................................................................................... 99
Figure 50. Wye Service with 3-Pole Breaker ........................................................................... 101
Figure 51. Delta Service with Delta/Wye Isolation Transformer and 3-Pole Breaker ............... 102
Figure 52. Wye Service with 4-Pole Breaker ........................................................................... 103
Figure 53. Delta Service with Delta/Wye Isolation Transformer and 4-Pole Disconnect .......... 104
Figure 54. Communication and Control Overview ................................................................... 108
Figure 55. E-Stop Connections ............................................................................................... 111
Figure 56. Multiple Microturbine (RS-485) Connections .......................................................... 113
Figure 57. Battery Wakeup Connection ................................................................................... 114
Figure 58. Modbus Connections ............................................................................................. 114
Figure 59. Typical Power Meter Installation ............................................................................. 115
Figure 60. Typical Remote Start/Stop Connection ................................................................... 116
Figure 61. DMSC Terminal Block Connections ....................................................................... 117
Figure 62. Fault Input Connections ......................................................................................... 117
Figure 63. Digital Communications Connections for Dual Mode CLC and Two C1000s .......... 120
Figure 64. Example Connections from a Dual Mode CLC to a C1000 ..................................... 121
List of Tables
Table 1. Referenced Documents ............................................................................................... 13
Table 2. Gaseous Fuel Connection Specifications .................................................................... 30
Table 3. Liquid Fuel Connection Specifications ......................................................................... 31
Table 4. N – L1 – L2 – L3 Lug Specifications ............................................................................ 34
Table 5. Ground Bar Specifications ........................................................................................... 34
Table 6. Power Cable Sets........................................................................................................ 35
Table 7. Heater Power Connections .......................................................................................... 35
Table 8. Terminal Block Wire Specifications ............................................................................. 38
Table 9. Microturbine Component Weights ............................................................................... 40
Table 10. Air Flow Requirements at ISO Conditions with Zero Backpressure ........................... 50
Table 11. Heat Rejection per Microturbine Model ...................................................................... 50
Table 12. Overcurrent Protection Sizing .................................................................................... 70
Table 13. Recommended Transformer Sizes (Per System) ....................................................... 73
Table 14. Grid Connect Allowable Configurations Matrix .......................................................... 78
Table 15. External RS485 Connections at TB1 ....................................................................... 112

Capstone Microturbine C1000 Series Specifications

General

Brand	Capstone
Model	Microturbine C1000 Series
Category	Controller
Language	English